SP-7XE/F Full-Rise Scissor Lift 23 P/N 5900010 — Rev. B3 — September 2023
Lift the Platforms Off the Bases SP-7XE/XEF
Raise the Platforms off the Bases to access the anchor points. When you raise the Lift
Platforms make sure to leave it engaged on a Safety Lock.
NOTICE BendPak strongly recommends raising the Platforms to the Top Safety Lock, to
provide enough room under the Platform to install the Anchor Bolts and make the
Hydraulic and pneumatic connections.
⚠ WARNING Do not place any part of your body under the Platform while it is being raised. Use a
wood 2 x 4 or other suitable device to hold the Base in position until the Platform is
secure on a Safety Lock.
⚠ WARNING You must always wear OSHA-approved (Publication 3151) Personal Protective
Equipment when installing the Lift: leather gloves, steel-toed boots, eye protection,
back belts, and hearing protection are mandatory.
To lift the Platforms off the Bases:
1. Use Crowbars to lift the Platforms off their Bases, then carefully, slip a rope, chain, or industrial
strap (sling) under each end of the Platform.
Tip Once the Platform and Base are separated by more than .5 in. (≈13 mm), you may use
industrial slings (straps) around each end to continue raising the Platform off the Base.
⚠ WARNING Beware of all pinch points and crush hazards. Always keep hands and feet clear.
⚠ WARNING BendPak strongly recommends using at least
three people to lift the Platforms off their Bases:
one person on each end to hold down the Base
and one person to operate the Forklift or Shop
Crane to raise the Platform. Use care when
raising the Platforms off their Bases; they
are heavy and difficult
to hold.
⚠ WARNING You must always wear
OSHA-approved
(publication 3151) Personal
Protective Equipment when
installing the Lift: leather
gloves, steel-toed boots,
eye protection, back belts,
and hearing protection are
mandatory.
2. Using a Forklift or Shop Crane, carefully
raise the Platform off its Base.
3. When the Platform is raised to the Top
Safety Lock, lower it back down and leave
the platform on that Top Safety Lock.
To Next Page
Loading...
