Bostitch CAP2045ST - User Manual

BEFORE OPERATING THIS COMPRESSOR, THE USER SHOULD STUDY THIS MANUAL TO
UNDERSTAND AND FOLLOW THE SAFETY WARNINGS AND INSTRUCTIONS. KEEP THESE
INSTRUCTIONS WITH THE COMPRESSOR FOR FUTURE REFERENCE. IF YOU HAVE ANY
QUESTIONS, CONTACT YOUR BOSTITCH REPRESENTATIVE OR DISTRIBUTOR.
OPERATION and MAINTENANCE MANUAL
MANUAL DE OPERACIÓN Y DE MANTENIMIENTO
MANUEL D’INSTRUCTIONS ET D’ENTRETIEN
AIR COMPRESSORS
122603REVA 6/01
®
®
®
CAP1580WB / CAP5580WB
CAP2045ST
CAP1545PT-OF / CAP1545PT-OL
GASOLINE UNITS OPERATION
See enclosed Honda Engine Manual for proper operation.
GENERAL MAINTENANCE AND SERVICE
Always note position and orientation of parts as removed to assure correct repositioning when
reassembling.
Air filter
Inspect air filter before each use. Clean filter pad with soap and water as necessary. If filter becomes
clogged or damaged, replace it.
Never clean air filter with a flammable liquid or solvent. Explosive vapors may
accumulate in the air tanks and cause an explosion, resulting in serious injury or death.
CAUTION: Do not operate air compressor without air filter.
Storage Tanks
Storage tanks should be drained after each use or after every four hours of operation to prevent
condensation build-up and corrosion inside tank. To drain tanks, slowly and carefully open drain
fittings tip unit towards drain and allow water to drain out.
NOTE: When draining tanks, watch for debris (rust particles). If there appears to be debris in water,
contact your dealer for possible tank replacement.
Failure to regularly drain tank may cause tank corrosion and risk of tank explosion,
resulting in serious injury. To avoid risk of tank failure during use, drain tank after each use or every
four hours to prevent condensation build-up and corrosion inside tank.
If warranty service or repairs are needed contact your nearest authorized service center. If one does
not exist, contact the factory. Unauthorized teardown of the unit will void the factory warranty.

Summary

General Maintenance and Service

Air Filter

Inspect and clean the air filter pad with soap and water. Replace if clogged or damaged.

Storage Tanks

Drain tanks after each use or every four hours to prevent condensation build-up and corrosion.

Introduction

Limited Warranty

Specifications

CAP2045 ST-OL Specifications

Technical details for the CAP2045ST-OL air compressor model.

CAP1580 WB Specifications

Technical details for the CAP1580WB air compressor model.

CAP5580 WB Specifications

Technical details for the CAP5580WB air compressor model.

Specifications Continuation

CAP1560 Specifications

Technical details for the CAP1560 air compressor model.

CAP1545 PT-OF Specifications

Technical details for the CAP1545PT-OF air compressor model.

CAP1545 PT-OL Specifications

Technical details for the CAP1545PT-OL air compressor model.

Rules for Safe Operation

Assembly

CAP1560 Assembly

Steps for assembling the CAP1560 air compressor model.

Electrical Grounding Instructions

Electric Units Operation

Bostitch CAP2045ST Specifications

General

Brand	Bostitch
Model	CAP2045ST
Category	Air Compressor
Language	English