Bruce BR3000-330-2CL - Table 12 BC1-0230 Series LCM Parts List; Figure 25 IPL Illustration, BC1-0230-003 LCM Unit

81 pages

Save Page as PDF

To Next Page

To Previous Page

BR3000-330-2CL,-3CL,-2EN CMM and IPL

Figure 25 IPL Illustration, BC1-0230-003 LCM Unit

Table 12 BC1-0230 Series LCM Parts List

FIGURE

ITEM

PART NUMBER

AIRLINE

STOCK NO.

NOMENCLATURE

VENDOR

CODE

MLS SYSTEM

APPLICABILITY

UNITS

PER

SYSTEM

1 BC1-0230-001

LCM Unit, 35-

Inch, Hat-Rack

17023 BR3000-330-2CL 29

2 BC1-0230-002

LCM Unit, 35-

Inch, Sidewall

17023 BR3000-330-2CL 53

3 BC1-0230-003

LCM Unit, 35-

Inch, Ceiling

17023 BR3000-330-2CL 68

Document No. 33-21-57, Rev. A

Page 61

Main Page

Table of Contents3
Scope7
Manufacturer Product Support Information7
How to Use this Manual7
Warnings, Cautions, and Notes8
Warning8
Caution8
Note8
General Safety Precautions8
Electrostatic Discharge8
Modification of Equipment8
Abbreviations and Unit Symbols9
Reference Documents9
United States Government9
Industry Documents9
Table 1 Abbreviations and Unit Symbols9
Equipment Overview10
Figure 1 Basic BR3000 MLS Architecture, Business Class Zone12
Figure 2 Basic BR3000 MLS Architecture, Economy Class Zone13
Unit Descriptions14
Bc1-0212 Mlcp14
Figure 3 BC1-0212 Mood Lighting Control Panel (MLCP)18
Figure 4, MLCP Connector Pin-Out19
Table 2 BC1-0212 MLCP Connector Pin-Out20
Figure 5 MLCP Block Diagram21
LCM Units22
Table 3 BR3000-330-2CL MLS Equipment Complement23
Figure 6 BC1-0229-XXX LCM Unit, Rear View26
Figure 7 BC1-0230-XXX LCM Unit, Rear View27
Figure 8 BC1-0229-XXX and BC1-0230-XXX LCM Connector Pin-Out28
Figure 9 LCM Unit, Basic Architecture29
Figure 10 LCM Unit, Input Module, Block Diagram30
Figure 11 LCM Unit, LED Driver and LED Board, Block Diagram31
BC1-0216 CAN Bus Terminator32
Figure 12 BC1-0216 CAN Bus Terminator32
Figure 13 BC1-0216 CAN Bus Terminator Pin-Out33
Br3000 Mls System Operation34
BR3000-330-2CL & -3CL MLS System Operation34
MLS System Power-Up Procedure34
Power-Up Procedure34
Figure 14 MLCP Power Switch Location35
Figure 15 Lighting Control Switches on A330 Legacy Control Panel36
MLS System Reset37
Scenario Execution38
Figure 16 Scenario Function Buttons38
Test Function39
Decompression Override40
Scenario Re-Programming40
Maintenance41
Vendor Codes41
Table 4 Vendor Codes41
Outline and Mounting Information42
BR3000 MLS Unit Identification42
Wiring Information42
Figure 17 Identification Marking43
Scheduled Maintenance44
Daily Check44
Tools and Equipment, Daily Check44
BR3000 MLS LRU Testing and Fault Isolation45
Tools and Equipment, Operational Test and Fault Isolation45
Power-Up Procedure45
Figure 18 Operational Level Troubleshooting Flowchart46
Test Scenario Execution: LCM LED Check47
Data Cable Testing47
Lru Removal & Replacement49
BR3000-330-2CL MLS System, LRU Removal & Replacement49
Br3000 Lru Cleaning & Inspection52
Cleaning Instructions52
Table 5 Recommended Cleaning Materials52
BR3000 MLS Inspection53
Br3000 Mls Repair and Bench Testing54
BR3000 LRU Bench Testing55
Table 6 Special Tools and Equipment55
Table 7 BR2900 LCM Input Current Test Parameters56
Table 8 MLCP Scenarios in Lab Test Mode58
Figure 19 BR3000 Bench Test Harness59
Figure 20 BR3000 LRU Bench Test Configuration60
BR3000 MLS, LRU Storage61
Illustrated Parts List (Ipl)62
Purpose62
Guide to the Use of this IPL62
Manufacturer Names and Addresses62
Table 9 Vendor Codes and Addresses62
Table 10 BC1-0212-001 MLCP Parts List63
Figure 21 BC1-0212-001 Mood Lighting Control Panel (MLCP)63
Figure 22 IPL Illustration, BC1-0229-001, -002 LCM Units64
Table 11 BC1-0229 Series LCM Parts List65
Figure 23 IPL Illustration, BC1-0229-003 LCM Unit65
Figure 24 IPL Illustration, BC1-0230-001, -002 LCM Units66
Table 12 BC1-0230 Series LCM Parts List67
Figure 25 IPL Illustration, BC1-0230-003 LCM Unit67
Table 13 BC1-0216-001 CAN Bus Terminator Parts List68
Figure 26 BC1-0216-001 CAN Bus Terminator68
Inclusion of LRU Part Number Information69
Appendix A, Outline and Mounting Drawings, Br3000-330-2Cl Mls70

Bruce BR3000-330-2CL - Table 12 BC1-0230 Series LCM Parts List; Figure 25 IPL Illustration, BC1-0230-003 LCM Unit

Table of Contents