Residential Air Conditioners and Heat Pumps Using R-22 and PuronĀ® Refrigerant: Application Guideline and Service Manual
Manufacturer reserves the right to change, at any time, specifications and designs without notice and without obligations.
2
Communication and Status Function Lights For
Evolution Control only, Green communications (COMM) Light 55
Utility Interface With Evolution Control . . . . . . . . . . . . . . . . . . . 55
Compressor Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Fan Motor. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Time Delays . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Pressure Switches. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Muffler, Accumulator, Reversing Valve (RVS) . . . . . . . . . . . . . 57
Thermistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Control Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Troubleshooting circuit board
HK38EA016, 022, 023, 026. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Systems Communication Failure . . . . . . . . . . . . . . . . . . . . . . . . . 58
Model Plug. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Pressure Switch Protection. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Control Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Brown-Out Protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
230v Brown-Out Protection Defeated . . . . . . . . . . . . . . . . . . . . . 59
230V Line (Power Disconnect) Detection . . . . . . . . . . . . . . . . . . 59
Compressor Voltage Sensing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Contactor Shorted Detection . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Compressor Thermal Cutout . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
180B/187B/286B/289B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Low or High Contactor Open/No 230V at
Compressor Contractor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
180B/187B/286B/289B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Troubleshooting units for proper switching
between low & high stages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
180B/187B/286B/289B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Unloader Test Procedure
180B/187B/286B/289B . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Temperature Thermistors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Thermistor Sensor Comparison . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Failed Thermistor Default Operation. . . . . . . . . . . . . . . . . . . . . . 60
Two Stage Non-Communicating
127A/CA17/BA17CH17/BH17/226A . . . . . . . . . . . . . . . . . . . . . . . 62
Operating Ambient. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Airflow Selections (ECM Furnaces) . . . . . . . . . . . . . . . . . . . . . . 62
Airflow Selection for
Variable Speed Furnaces (non-communicating) . . . . . . . . . . . . . 62
Airflow Selection for FV4C Fan Coils
(non-communicating). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Airflow Selection for FZ4A Fan Coils
(non-communicating). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
System function and Sequence Of Operation
(127A/226A/CA17/CH17/BA17/BH17) . . . . . . . . . . . . . . . . . . . . . 63
Compressor Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Quiet Shift . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Quiet Shift-2 (non-communicating). . . . . . . . . . . . . . . . . . . . . . . 63
Defrost . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Defrost Speedup. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
CHECK CHARGE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Heating Check Chart Procedure. . . . . . . . . . . . . . . . . . . . . . . . . . 64
Verify 226A / CH17 units for proper switching between low & high
stages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
Unloader Test Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
CARE AND MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Desert and Seacoast Locations. . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Cleaning Coil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Cleaning Outdoor Fan Motor and Blade . . . . . . . . . . . . . . . . . . . 65
Electrical Controls and Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . 66
Refrigerant Circuit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
Final Check-Out. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66
INDEX OF TABLES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70