Chamberlain MEGA SWING User Manual

2
INTRODUCTION
Carton Inventory. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Manual Release . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
UL325 Model Classifications . . . . . . . . . . . . . . . . . . . . . . . . . .4
Safety Installation Information . . . . . . . . . . . . . . . . . . . . . . . . .5
Safety Precautions for Swing and Ornamental
“Grill Type Gates”. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Warning Sign Placement . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6
Recommended Photo Cell Layout
for Secondary Entrapment Protection . . . . . . . . . . . . . . . . . . .7
Operator Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
INSTALLATION
Concrete Pad . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Anchors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Conduits. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Safety Edge Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Drive Arm Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
WIRING AND HOOKUP
AC Power Hookup (120/230 Vac) . . . . . . . . . . . . . . . . . . . . .10
Input Commands Connections . . . . . . . . . . . . . . . . . . . . . . . .11
Accessory Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Battery Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Master/Second Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
TIMERS AND MODE SELECTIONS S1 & S2
Fast Run Timer - Switch Pack S1 (1-5) . . . . . . . . . . . . . . . . .13
Mode Selections - Switch Pack S1 (6-8) . . . . . . . . . . . . . . . .13
Close Timer - Switch Pack S2 (1-5). . . . . . . . . . . . . . . . . . . .13
Mode Selections - Switch Pack S2 (6-8) . . . . . . . . . . . . . . . .13
ADJUSTMENTS
Right or Left Hand Operation . . . . . . . . . . . . . . . . . . . . . . . . .14
Limit Switch Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Instant Reverse Device (IRD) . . . . . . . . . . . . . . . . . . . . . . . . .14
INSTALL THE RECEIVER
Set Security Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Programming the Remote to the Receiver . . . . . . . . . . . . . . .15
To Erase All Remote Control Codes . . . . . . . . . . . . . . . . . . . .15
MAINTENANCE
General Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Maintenance/Testing . . . . . . . . . . . . . . . . . . . . . . . . .16
Battery Handling/Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
TROUBLESHOOTING
Battery Checkout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
Gate Not Operating. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17
SUGGESTED LOOP SENSOR LOCATIONS
Free Exit on Vehicle Approach . . . . . . . . . . . . . . . . . . . . . . . .18
Entry With Access Control Device . . . . . . . . . . . . . . . . . . . . .18
Dual Direction as Entry and Free Exit . . . . . . . . . . . . . . . . . . .18
CONTROL BOARD LAYOUT
Component Locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
TABLE OF CONTENTS
IMPORTANT NOTES
• BEFORE attempting to install, operate or maintain the operator,
you MUST read and fully understand this manual and follow all
safety instructions.
• DO NOT attempt repair or service of your commercial door and
gate operator unless you are an Authorized Service Technician.
INTRODUCTION
Mechanical
Electrical
ATTENTION
AVERTISSEMENT AVERTISSEMENT
AVERTISSEMENT
WARNINGWARNING
CAUTION
WARNING
WARNING
PRECAUCIÓN
ADVERTENCIA
ADVERTENCIAADVERTENCIA
ATTENTION
AVERTISSEMENT AVERTISSEMENT
AVERTISSEMENT
WARNING
CAUTION
WARNINGWARNING
WARNING
PRECAUCIÓN
ADVERTENCIA
ADVERTENCIAADVERTENCIA
ATTENTION
AVERTISSEMENT AVERTISSEMENT
AVERTISSEMENT
WARNING
CAUTIONCAUTION
WARNING
WARNING
PRECAUCIÓN
ADVERTENCIA
ADVERTENCIAADVERTENCIA
When you see these Safety Symbols and Signal Words on the
following pages, they will alert you to the possibility of SERIOUS
INJURY or DEATH if you do not comply with the warnings that
accompany them. The hazard may come from something
mechanical or from electric shock. Read the warnings carefully.
When you see this Signal Word on the following pages, it will
alert you to the possibility of damage to your gate and/or the gate
operator if you do not comply with the cautionary statements that
accompany it. Read them carefully.
REPAIR PARTS 20
ACCESSORIES 21
SAFETY ACCESSORIES FOR SECONDARY
ENTRAPMENT PROTECTION 21
WARRANTY 22
REPAIR PARTS AND SERVICE 23
INSTALLATION CHECK OFF LIST 24

Chamberlain MEGA SWING Specifications

General

Brand	Chamberlain
Model	MEGA SWING
Category	Gate Opener
Language	English