What to do if my Char-Broil Grill burner will not light using the ignitor?
If the burner on your Char-Broil Grill won't light with the ignitor: * If the rotary knob rotates without clicking, replace the knob. * If sparking occurs between the ignitor and electrode, inspect the wire insulation and ensure a proper connection. Replace the wire if the insulation is broken.
Why is there a sudden drop in gas flow or low flame on my Char-Broil Grill?
A sudden drop in gas flow or low flame in your Char-Broil Grill could be due to: * Being out of gas: Check the gas level in the LP cylinder. * The excess flow valve on the regulator tripped: Turn off the control knob, wait 30 seconds, and then light the appliance. If the flames remain low, turn off the knob and LP cylinder valve, disconnect the regulator, reconnect it, and perform a leak test. Then, turn on the LP cylinder valve, wait 30 seconds, and light the appliance. * Vapor lock at the coupling nut/LP cylinder connection: Turn off the knob and LP cylinder valve, disconnect the coupling nut from the cylinder, reconnect it, and try again.
What to do if flames blow out on my Char-Broil THE BIG EASY 12101550?
If the flames on your Char-Broil Grill blow out, it could be due to: * Low LP gas: Refill the LP cylinder. * Excess flow valve tripped: Refer to the troubleshooting steps for a sudden drop in gas flow.
Why does my Char-Broil THE BIG EASY 12101550 have flare-ups?
Flare-ups in your Char-Broil Grill can occur due to several reasons: * Grease buildup: Clean the burner and the inside of the fryer body. * Excessive fat in meat: Trim fat from meat before grilling. * Excessive cooking temperature: Lower the cooking temperature.
What to do if my Char-Broil THE BIG EASY 12101550 is cooking slower than expected?
If your Char-Broil Grill is cooking slower than expected: * Vapor Lock: Turn off the control knob and disconnect the coupling nut from the LP cylinder. Reconnect and retry. * Valve not properly aligned to burner: Loosen the control panel and valve. Be sure the valve is centered top to bottom and left to right in the burner. Tighten all components once proper alignment is achieved. * High wind conditions: Relocate the appliance to a less windy area. Use a Top Cover during cooking.
What to do for a persistent grease fire on my Char-Broil THE BIG EASY 12101550?
If you have a persistent grease fire on your Char-Broil Grill: Turn the knob to OFF and turn off the gas at the LP cylinder. Let the fire burn out. After the fryer cools, remove and clean all parts.
What to do if there is a flashback (fire in burner) in my Char-Broil THE BIG EASY 12101550?
If you experience a flashback (fire in the burner) in your Char-Broil Grill: Turn the knob to OFF and clean the burner.
Why am I unable to fill the LP cylinder for my Char-Broil Grill?
If you're unable to fill the LP cylinder for your Char-Broil Grill, it may be because some dealers have older fill nozzles with worn threads. These worn nozzles might not have enough "bite" to engage the valve. Try a second LP dealer.
Covers initial CAUTION and WARNING boxes regarding safe assembly and operation.
Details immediate actions to take if a gas leak is detected, including shutting off gas.
Details LP cylinder requirements, safe filling practices, and storage precautions.
Explains the process for exchanging cylinders and performing leak tests.
Step-by-step guide on how to connect the regulator to the LP cylinder.
Covers installing the heat shield, control panel, and ignitor wiring.
Covers responses to gas leaks, fires, and other critical emergencies.
Addresses problems related to the burner not lighting or having improper flame.
General| Cooking System | Infrared |
|---|---|
| Fuel Type | Propane |
| Cooking Area | 180 sq. in. |
| Material | Steel |
| Ignition Type | Electronic |
| Product Type | Smoker |
| Dimensions | 23.4 in x 23.4 in x 36.2 in |
| Weight | 51 lb |
To Next Page