Cornelius OLYMPUS Series - User Manual

60 pages

Save Page as PDF

To Next Page

OLYMPUS

Post-Mix Beverage Dispenser

SERVICE MANUAL

IMI CORNELIUS ( TIANJIN ) CO., LTD

Main Page

Questions and Answers

K
kelly63Nov 16, 2025
Why is the refrigeration compressor not operating on my Cornelius OLYMPUS?
- E
  Elijah StephensNov 17, 2025
  If the refrigeration compressor in your Cornelius Beverage Dispenser isn't operating, check the following: * Ensure there is water in the water tank and that the control board power switch on top of the unit is in the 'ON' position (note the 3-minute delay before the compressor starts). * Verify the unit and drop-in refrigeration assembly power cords are plugged in. * Check the ice sensor is electrically connected. * Ensure there is a power source by checking for blown fuses or tripped circuit breakers. * Address any low/high voltage issues. * Inspect for loose, disconnected, or broken wiring. * Allow the compressor to cool if the overload protector cut out due to overheating. * Replace any inoperative overload protector, start relay, or ice bank probe. Finally, replace ...
N
Natalie PittmanNov 24, 2025
Why does my Cornelius Beverage Dispenser produce foamy drinks?
- L
  Laura ReynoldsNov 24, 2025
  If your Cornelius Beverage Dispenser is dispensing foamy product, several factors could be responsible. The refrigeration system's recovery rate may be exceeded, depleting the ice bank. Try allowing the ice bank to recover. The primary CO 2 regulator pressure could be too high for the water conditions or temperature; reduce the pressure settings. If you have a tanks system, the syrup might be over-carbonated; relieve the tank CO 2 pressure. Also, the dispensing valve might be restricted or dirty; sanitize the syrup system. A distorted tapered gasket inside the carbonated water line swivel nut connector could be restricting water flow; replace the gasket, ensuring it's properly seated. Check the water filter and replace the cartridge if it's dirty. Finally, ensure the finished drink is not ...