Cure It GRP - General Information; Product Description; Material Features; Longevity

4
General information
Cure It Data sheet
Product description
ACureItGRProofisasingle-plyGRPlaminateconsistingofCureItRoongResinandReinforcementMatappliedinsituoveragoodquality
OSB3deck.Theroofisnishedwithpre-formedGRPedgetrimsandacoatofpre-pigmentedCureItTopcoat.
Material features
-Materialsarespeciallyformulatedforroongapplications
- 20 year guarantee on materials
- Fast ‘wet-out’
- Low styrene emission
-Highexibility
- Adjusted for seasonal variations in temperature
- Good topcoat bonding characteristics
- Includes technical support
- Full training and on-site support available
- Supplied pre-pigmented Graphite Grey (BS 00 A 13)
- Range of colours available
- Fire retardant to BS476-3:2004 (no restrictions on usage)
-Suitableforfoottrafcapplicationswith600g/m²ReinforcementMat
Longevity
TheCureItroongsystemmaterials(CureItRoongResin,CureItRoongTopcoat,RoongEdgeTrims,Hardener,ReinforcementMat)will
remainwithinthespecicationoftheCureItMaterialSafetyDataSheetwhenstoredcorrectlyandwillformastructuralwaterproofmembrane
thatwillremainwatertightforaperiodof20yearsfromthedateofmanufacturewheninstalledasspeciedintheconditionssetoutinthe
Cure It guarantee.
Properties in relation to re
AatroongsystemcomprisingofaCureItGRPlaminatewithCureItTopcoatwhentestedtoBS476-3:2004wasdesignatedEXT.F.AB
(nolimitationsonuse).F.AAratingisavailablewiththeexposedaggregatenish.
Resistance to wind uplift
TheCureItGRProongsystemisfully-bondedtotheroofsubstrate.Thesystemwillberesistanttoanywindupliftthatcouldreasonablybe
expected during the product’s lifespan.
Areas of usage
TheCureItwaterproongsystemcanbeusedforwaterproongapplicationsofalmostanysizeorcomplexity.
Warm roof specication
TheCureItsystemcanbespeciedtocomplywithcurrentpart‘L’regulations.(seepage24)
Resistance to foot trafc
In standard 450g/m
2
specicationtheCureItsystemwillberesistanttoanyleveloffoottrafcthatitcouldreasonablybesubjectedtoduring
its lifespan. 600g/m
2
specicationisavailableforapplicationssubjecttoheavyfoottrafcsuchaswalkways/balconies.
Finish options
TheCureItwaterproongsystemissuppliedtoBS480000A13GraphiteGrey.Therearetwonon-slipoptionsavailable:exposedaggregate
(granulated non-slip slate coating applied at 0.75kg/m
2
)andcoatedaggregatenish(granulatednon-slipslatecoatingappliedat0.15kg/m
2
).
Standard Specication
OSB3 18mm T & G
CureItRoongResin@1.5kg/m
2
Cure It approved Reinforcement Mat
CureItRoongTopcoat@0.4kg/m
2
Cure It Hardener (1-4%)
Cure It GRP edge trims
Trim adhesive applied around the perimeter
Applied as per the Cure It Installation Manual