2 - 3
GENERAL SPECIFICATIONS
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
2
MODEL: SHUTTLE™ 2
TYPE: ELECTRIC DRIVE CARGO CARRIER
MODEL YEAR: 2012
Part No:. 618848
Precision Drive System™ (PDS): Factory programmable to application
Solid State continuously variable seperately ex cited speed controller
Eight, 6 Volt Deep Cycle
Dash mounted direction selector switch (Forward-Neutral-Reverse) Full torque, reduced speed rev erse
Anti-roll back, walkaw ay braking and alarm Inductiv e throttle sensor
Anti-stall motor protection
Diagnostic indicator
Regenerativ e ’Pedal Dow n’ and/or ‘Pedal U p’ braking
Factory selectable performance options
Battery Charger: 48 VDC Lester Pow erWise™, 120 VAC , U nderw riters Laboratories (U .L.) Listed, (C .S.A. C ertified)
Motor: 48 v olt DC shunt wound, brazed armature, solid copper w indings. Intermittant H orsepow er 18.1 hp (13.5 kW) at 1900 rpm (1hour)
Drive T rain: Direct motor shaft connected to transax le pinion shaft
Electrical System: 48 Volt DC, eight, 6 v olt deep cy cle storage batteries (107 minute, 225 amp-hour @ 20 hr. discharge rate)
T ransaxle: Differential w ith helical gears
Brakes: Dual rear w heel mechanical self-adjusting drum brakes. Automatic single point park brake release with self-compensating sy stem
Performance
Ov erall Length 138.5 in (352.0 cm) Seating C apacity 2 Person
Ov erall Width 46.5 in (119.0 cm)
Dry Weight 720 lb (325 kg) (Without Batteries)
Ov erall Height (N o C anopy ) 48.6 in (123.0 cm) (Top of steering wheel)
Curb Weight 1210 lb (550 kg)
Ov erall Height (With Canopy ) 74.0 in (188.0 cm)
Vehicle load capacity 1000 lb (540 kg)
Wheel Base 93.5 in (237.0 cm)
Outside C learance C ircle 25.5 ft (7.8 m)
Front Wheel Track 34.2 in (85.0 cm)
Intersecting Aisle Clearance N/A
Rear Wheel Track 38.0 in (97.0 cm)
Ground Speed (Lev el Ground) 13 mph ± 0.5 mph (21 kph ± 0.8 kph)
Gnd Clearance @ Differential 4.3 in (11.0 cm)
Towing Capacity N/A
Cargo Bed Width 44.0 in (112.0 cm)
Steering & Suspension
Cargo Bed Length 68.5 in (174.0 cm)
Steering Self-compensating rack and pinion
Vehicle Power
Front Suspension Leaf springs w ith hy draulic shock absorbers
Pow er Source 48 Volts DC
Rear Suspension Leaf springs with hy draulic shock absorbers
Motor Type Shunt Wound
Serv ice Brake Rear wheel mechanical self-adjusting drum
Continuous H orsepow er (kW) 2.5 hp (1.9 kW)
Parking Brake Self-compensating, single point engagement
Intermittent Horsepow er (kW) 18.1 hp (13.5 kW) @ 1900 rpm
Front Tires Links 18 x 8.50 - 8 (4 Ply Rated)
Electrical System 48 Volt
Rear Tires Links 18 x 8.50 - 8 (4 Ply Rated)
Batteries (Qty , Ty pe) Eight, 6 Volt Deep Cy cle
Body & Chassis
Key or Pedal Start Pedal Start
Frame Welded steel. DuraShield™ pow der coat
Battery C harger 48 V Lester Pow erWise, 120 VAC , UL/C SA
Front Body & Finish Injection molded TPO. Base coat/clear coat
Speed C ontroller 400 Amp Precision Driv e Sy stem (PDS)
Rear Body & Finish Steel. Base coat/clear coat
Driv e Train Motor Shaft Direct Driv e
Standard Color Champagne
Transax le Differential w ith helical gears
Gear Selection Dash Mounted Forw ard-N eutral-Rev erse
Rear Ax le Ratio 14.7:1
Some items shown may be optional equipment
PRODUCT SPECIFICATION
CONFIGURATION HIGHLIGHTS
PRODUCT OVERVIEW
Dimensions
Specications are subject to change without notice
* Field installed accessories may require installation charges
Noise & Vibration
Sound pressure; continued A-weighted equal to or
less than 70 db(A)
Highest RMS value of weighted acceleration is 1.23 m/s
2
Highest RMS value of weighted acceleration is less than
2.5 m/s
2
The uncertainty of measurement is 0.69 m/s
2
Noise
Vibration, WBV
Vibration, HAV
To Next Page
Loading...
