2 - 5
GENERAL SPECIFICATIONS
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.
2
MODEL: SHUTTLE™ 6
TYPE: ELECTRIC POW ERED PERSONNEL CARRIER
MODEL YEAR: 2012
Part No:. 618852
Precision Drive System™ (PDS): Factory programmable to application
Solid State continuously variable seperately ex cited speed controller
Eight, 6 Volt Deep Cy cle
Dash mounted direction selector sw itch (Forw ard-N eutral-Rev erse)
Full torque, reduced speed rev erse
Anti-roll back, w alkaw ay braking and alarm
Inductiv e throttle sensor
Anti-stall motor protection
Diagnostic indicator
Regenerativ e ’Pedal Down’ and/or ‘Pedal U p’ braking
Factory selectable performance options
Battery Charger: Delta Q, 48 VDC . H 120/230 VAC 50/60 H z. U nderw riters Laboratories (U .L.) Listed, (C .S.A. C ertified)
Motor: 48 v olt DC shunt wound, brazed armature, solid copper w indings. Intermittant H orsepow er 18.1 hp (13.5 kW) at 1900 rpm (1hour)
Drive T rain: Direct motor shaft connected to transax le pinion shaft
Electrical System: 48 Volt DC, eight, 6 v olt deep cy cle storage batteries (107 minute, 225 amp-hour @ 20 hr. discharge rate)
T ransaxle: Differential w ith helical gears
Brakes: Dual rear w heel mechanical self-adjusting drum brakes. Automatic single point park brake release w ith self-compensating sy stem
Performance
Ov erall Length 133.5 in (339.0 cm) Seating C apacity 6 Person
Ov erall Width 46.5 in (119.0 cm)
Dry Weight 720 lb (325 kg) (Without Batteries)
Ov erall Height (N o C anopy ) 48.6 in (123.0 cm) (Top of steering wheel)
Curb Weight 1210 lb (545 kg)
Overall Height (With Canopy) 72.0 in (183.0 cm)
Vehicle load capacity 1198 lb (540 kg)
Wheel Base 93.5 in (237.0 cm)
Outside C learance C ircle 25.5 ft (7.8 m)
Front Wheel Track 34.2 in (86.7 cm)
Speed (Lev el Ground) 13 mph ± 0.5 mph (21 kph ± 0.8 kph)
Rear Wheel Track 38.0 in (97.0 cm)
Tow ing C apacity N /A
Gnd Clearance @ Differential 4.3 in (11.0 cm)
Steering & Suspension
Vehicle Power
Steering Self-compensating rack and pinion
Power Source 48 Volts DC
Front Suspension Leaf springs w ith hy draulic shock absorbers
Motor Type Shunt Wound
Rear Suspension Leaf springs w ith hy draulic shock absorbers
Continuous H orsepow er (kW) 2.5 hp (1.9 kW)
Serv ice Brake Rear w heel mechanical self-adjusting drum
Intermittent Horsepow er (kW) 18.1 hp (13.5 kW) @ 1900 rpm
Parking Brake Self-compensating, single point engagement
Electrical Sy stem 48 Volt
Front Tires Links 18 x 8.50 - 8 (4 Ply Rated)
Batteries (Qty , Ty pe) Eight, 6 Volt Deep Cy cle
Rear Tires Links 18 x 8.50 - 8 (4 Ply Rated)
Key or Pedal Start Pedal Start
Body & Chassis
Battery C harger 48 VDC Delta Q, 120/230 VAC , U L & C SA
Frame Welded steel. DuraShield™ pow der coat
Speed C ontroller 400 Amp Precision Driv e Sy stem (PDS)
Body & Finish Injection molded TPO
Driv e Train Motor Shaft Direct Driv e
Seat Pod Fiberglass & Gelcoat
Transax le Differential w ith helical gears
Standard Color Champagne
Gear Selection Dash Mounted Forw ard-N eutral-Rev erse
Rear Axle Ratio 14.7:1
Some items shown may be optional equipment
CONFIGURATION HIGHLIGHTS
PRODUCT SPECIFICATION
PRODUCT OVERVIEW
Dimensions
Specications are subject to change without notice
* Field installed accessories may require installation charges
Noise & Vibration
Sound pressure; continued A-weighted equal to or
less than 70 db(A)
Highest RMS value of weighted acceleration is 1.23 m/s
2
Highest RMS value of weighted acceleration is less than
2.5 m/s
2
The uncertainty of measurement is 0.69 m/s
2
Noise
Vibration, WBV
Vibration, HAV
To Next Page
Loading...
