Maintenance Section
-167-
Battery Terminal - Clean, Inspect
WARNING
Batteries give off flammable fumes that can
explode.
Do not smoke when observing the battery
electrolyte levels.
Electrolyte is an acid and can cause personal
injury if it contacts skin or eyes.
Always wear protective glasses when working
with batteries.
1. Clean the top of the battery and terminals.
2. Check terminals for corrosion. Coat terminals
with heavy grease.
Engine Oil & Filter (DB33A Diesel,
LP-Gas & Gasoline Engine Only) -
Change
DB33A Diesel Engine Crankcase
See topic, “Engine Oil & Filter (DB33A Diesel
Engine Only)-Change” in “First 50-100 Service
Hours”
Gasoline, LP-Gas Engine Crankcase
1. Operate lift truck a few minutes to warm oil.
Park the lift truck with the forks lowered, parking
brake applied, transmission in neutral and the
engine stopped.
2. Raise rear of lift truck off ground and block
securely.
WARNING
Hot oil and components can cause personal
injury. Do not allow hot oil or components to
contact skin.
3. Remove the crankcase drain plug and allow oil
to drain into a suitable container. Clean and
install drain plug.
4. Raise the hood and seat assembly.
To Next Page
Loading...
Need help?
General
