DAF XF95 - Page 34

MAINTENANCE SCHEDULE
2-2
©
200423
Maintenance activities
4
ΞΦ95 series
2.2 OVERVIEW OF ANNUAL MAINTENANCE ACTIVITIES
(1) Every 2 years with coolant according to
DAF specification 74001.
Every 4 years with coolant according to
DAF specification 74002.
(2) For changing interval see maintenance schedule in
maintenance manual.
(3) For changing interval see maintenance schedule in
maintenance manual.
When changing the gearbox oil on a gearbox with
intarder, the gearbox oil filter must also be renewed.
(4) Check the valve clearance every 2 years after the
2
nd
Y service and adjust if necessary
(example: 1
st
- 2
nd
- 4
th
- 6
th
... year).
(5) Once every 3 years at a maximum of 500,000 km.
(6) Every 2 years.
ANNUAL MAINTENANCE ACTIVITIES = Y-SERVICE INTERVAL
"Correct if necessary after inspection"
CAB AND ELECTRICAL SYSTEM
O Check pedal rubbers
O Check whether the latest version of the ITS manual is kept in the cab
O Replace interior filter element
O Check fluid level of cab tilting pump
O Check cab fastening
ENGINE, COOLING SYSTEM AND FUEL SYSTEM
O Replace air filter element
O Check air inlet dust trapping valve
O Check/adjust valve clearance
(4)
Done O Yes O No
O Replace coolant filter
O Check coolant freezing point
O Change coolant
(1)
Changed O Yes O No
STEERING GEAR AND BRAKE SYSTEM
O Replace steering gear filter element
(6)
Replaced O Yes O No
O Check steering ball joints
O Replace air dryer filter element
O Check compressor line
O Check automatic slack adjuster
O Check brake cylinder fastening
O Check/adjust load-dependent control valve
O Check fastening of universal joint to steering box input shaft
DRIVE AND CHASSIS
O Check fluid level of hydraulic trailing axle lifting device
O Check pivot points of hydraulic trailing axle lifting device
O Change the differential oil
(2)
Changed O Yes O No
O Change the hub oil
(2)
Changed O Yes O No
O Change grease of leading rear axle hubs of FTP-type
vehicles
(5)
Done O Yes O No
O Check operation of differential lock
O Check drive shaft play
O Change the gearbox oil
(3)
Changed O Yes O No
O Check fifth wheel
O Check trailer coupling
O Check superstructure attachment
OTHER ACTIVITIES
O Check whether there are any field actions that need to be performed on the vehicle.