25CC102/C/122/C/132/142/C M102EN4
DEUTZ
Loosen and screw off the fuel filter (1). Discard the filter
in a safe manner, it is not reusable and cannot be
cleaned.
See the engine manual for detailed instructions
on changing the fuel filter.
Start the engine and check that the fuel filter does not leak.
Make sure that ventilation (extraction) is
adequate if the engine is run indoors.
(Risk of carbon monoxide poisoning).
Replace the main filter (3) of the air cleaner even if it
has not yet been cleaned five times; see under the
heading ”Every 50 hours of operation” for changing the
filter.
If the filter is not replaced when clogged, the
engine will emit smoke and lose power and
there will be serious risk of damage to the
engine.
Condensation water in the hydraulic reservoir is drai-
ned via the plug (1). Draining must be done after the
roller has stood still during a long period—for example,
after standing still overnight.
Take great care when draining. Do not drop
the plug so that all the oil runs out.
Drain as follows:
Place a receptacle under the plug.
Unscrew and allow any condensation to drain off.
Tighten the plug.
Hydraulic reservoir – Draining
Fig. 39 Left side of frame
1. Drain plug
1
Changing the air cleaner
Fig. 40 Air cleaner
1. Filter housing
2. Backup filter
3. Main filter
Changing the fuel filter
Fig. 41 Engine compartment
1. Fuel filter
1
EVERY 1000 HOURS OF OPERATION (Every six months)
Place a receptacle underneath to collect fuel
that runs out when removing the filter.
1
2
3
To Next Page
Loading...
Need help?
General
