EHC SLIMJIM - Page Contents

3
GB-063C_f.615
Pleasereadandfollowtheinstallationoperatinginstructionscarefully,toensurethelonglifeandreliable
operationofthisappliance.
TheElectricHeatingCompanymaymakeminorchangeswhennecessarytotheappliancethatwillnotbe
showninthisdocument,solongasthemainfeaturesoftheboilerremainthesame.
Allboilerscomewitha24monthwarrantythatcoversalldefectsoriginatingfromfaultymaterialsandwork-
manshipinthemanufactureoftheboilers.
Thewarrantywillnotcoveranydamagetotheboilerfrompoororincorrectinstallationwork.Inadditionthe
WarrantywillnotcoveranycalloutchargesthathavenotbeenauthorisedbytheElectricHeatingCompanyLtd.
Thewarrantywillnotcoveranywaterleaksintotheboilerthatmaycausedamagetotheelectricalorelec-
troniccontrolsystem.
Allplumbingconnectionsmustbecheckedandautoairventspositionedtothesideoftheboilerandnot
directlyabovetheunit.
AMagneticFiltermustbeinstalledtotheboilersreturnpipeworkbeforethecirculationpump.Itisrecom-
mendedthatthelteriscleaned;failuretocleantheMagneticFiltermayresultinboiler/systemfailure.War-
rantycallswillnotbecoveredwheretheaboverequirementshavenotbeenmet.
The “Slim Jim” boiler is a low temperature boiler intended for use in unvented or vented central
heating systems with forced circulation.
(Protected according to legally binding directives).
This appliance is not intended for use by persons (including children) with reduced physical, sensory
or mental capabilities, or lack of experience and knowledge unless they have been given supervision
or instruction concerning the use of the appliance by a person responsible for their safety.
Children should be supervised to ensure that they do not operate or interfere with the appliance.
Page Contents
INTRODUCTION 3
PREPERATION 5
LOCATION 5
GENERAL 6
BOILER INTERNAL LAYOUT 8
INSTALLATION 9
SYSTEM PROTECTION - COMMISSIONING 11
ELECTRICAL CONNECTIONS 12
ELECTRICAL CONNECTIONS 14
CONTROL WIRING 16
BOILER CONTROL PANEL 17
TECHNICAL SPECIFICATION 18
PARTS LIST TABLE 19
INTRODUCTION