Fisher FIELDBUE DVC6200 User Manual

www.Fisher.com
Fisher
™
FIELDVUE
™
DVC6200 SIS Digital Valve
Controller
This manual applies to
Instrument Level SIS
Device Type 130a
Device Revision 1 & 2
Hardware Revision 2
Firmware Revision 4, 5 & 6
DD Revision 3, 4 & 5
Contents
Section 1 Introduction 3.................
Installation, Pneumatic and Electrical Connections,
and Initial Configuration 3.....................
Scope of Manual 3..............................
Conventions Used in this Manual 3................
Description 3..................................
Specifications 4................................
Related Documents 7...........................
Educational Services 8...........................
Section 2 Wiring Practices 9..............
Control System Requirements 9..................
HART Filter 9.................................
Voltage Available 9............................
Compliance Voltage 10........................
Auxiliary Terminal Wiring Length Guidelines 12....
Maximum Cable Capacitance 11.................
LCP100 Control Panel 13.........................
Installaton 13.................................
Electrical Connections 13.......................
Section 3 Configuration 15...............
Guided Setup 15...............................
Manual Setup 15...............................
Mode and Protection 17........................
Instrument Mode 17.......................
Write Protection 17........................
Instrument 17................................
Identification 17...........................
Serial Numbers 18.........................
Units 18..................................
Terminal Box 18...........................
Spec Sheet 18.............................
Edit Instrument Time 18....................
X0079
Travel/Pressure Control 19......................
End Point Pressure Control 19................
Characterization 19........................
Dynamic Response 21......................
Travel Cutoffs 21..........................
Tuning 21....................................
Travel Tuning 21...........................
Integral Settings 24........................
Valve and Actuator 24..........................
SIS/Partial Stroke Test 27.......................
Partial Stroke Test (PST) 27..................
SIS Options 30............................
Outputs 30...................................
Output Terminal Configuration 30............
Switch Configuration 31....................
HART Variable Assignments 31..............
Transmitter Output 31.....................
Burst Mode 31............................
Alert Setup 32.................................
Change to HART 5 / HART 7 34....................
Instruction Manual
D103557X012
DVC6200 SIS Digital Valve Controller
April 2016

Fisher FIELDBUE DVC6200 Specifications

General

Manufacturer	Fisher
Model	FIELDBUE DVC6200
Category	Controller
Type	Digital Valve Controller
Output Signal	Pneumatic
Operating Temperature	-40 to 85°C (-40 to 185°F)
Enclosure Rating	NEMA 4X, IP66
Certifications	ATEX, IECEx, CSA, FM
Communication Protocol	FOUNDATION fieldbus
Mounting	valve actuator
Input Signal	4-20 mA

Summary

Section 1 Introduction

Specifications

Section 2 Wiring Practices

Voltage Available

Explains required voltage and calculation for instrument operation.

Section 3 Configuration

Guided Setup

Travel/Pressure Control

Configures parameters related to valve travel and pressure control.

Tuning

Adjusts instrument parameters to optimize control loop performance.

Manual Setup

Allows detailed manual configuration of instrument parameters.

Mode and Protection

Configures instrument operational mode and write protection settings.

Section 3 Configuration

SIS/Partial Stroke Test

Configuration and execution of safety instrumented system (SIS) partial stroke tests.

Section 4 Calibration

Calibration Overview

Manual Calibration

Auto Travel Calibration

Section 5 Device Information, Diagnostics, and Alerts

Partial Stroke Test

Performing partial stroke tests to verify valve operation.

Section 6 Maintenance and Troubleshooting

General Maintenance Precautions

Troubleshooting

Appendix B Field Communicator Menu Trees

Figure B-5. Manual Setup > Mode Protection (2-2-1) and Manual Setup > Instrument (2-2-2)

Figure B-8. Alert Setup (2-3)