Grundfos IO 113 - 1 General Information; Table of Contents; Hazard Statements

English (GB)
2
English (GB) Installation and operating instructions
Original installation and operating instructions
These installation and operating instructions
describe Grundfos IO 113.
Sections 1-4 give the information necessary to be
able to unpack, install and start up the product in a
safe way.
Sections 4-12 give important information about the
product, as well as information on service, fault
finding and disposal of the product.
CONTENTS
Page
1. General information
1.1 Hazard statements
The symbols and hazard statements below may
appear in Grundfos installation and operating
instructions, safety instructions and service
instructions.
The hazard statements are structured in the
following way:
1. General information
2
1.1 Hazard statements
2
1.2 Notes
3
2. Receiving the product
3
3. Installing the product
3
3.1 General installation data
3
3.2 Location
4
3.3 Dimensions and mounting
4
3.4 EMC-compliant installation
5
3.5 Electrical connection
6
4. Configuring the product
8
4.1 Potentiometer
8
4.2 DIP switch configuration
8
4.3 Pump variant
9
4.4 Address for bus communication
10
4.5 SM 113 sensor detection and address
setting
11
4.6 Analog outputs
13
4.7 Bus protocol
14
4.8 ATEX/IEC Ex protection
14
4.9 Product type
15
5. Commissioning the product
16
6. Product introduction
16
6.1 Product description
16
6.2 Intended use
16
6.3 User interface
17
6.4 Indicator lights and their function
17
6.5 Description of indicator lights
18
6.6 Identification
19
6.7 Approval
19
6.8 Variants
19
6.9 Expansion using SM 113
19
6.10 WIO/WIA sensor
19
7. Control functions
20
8. Fault finding the product
23
9. Overview of alarms and warnings
24
9.1 Alarm resetting
24
10. Calibration
25
11. Maintenance and service
25
12. Disposing of the product
25
Read this document before installing the
product. Installation and operation must
comply with local regulations and accepted
codes of good practice.
DANGER
Indicates a hazardous situation which, if
not avoided, will result in death or serious
personal injury.
WARNING
Indicates a hazardous situation which, if
not avoided, could result in death or
serious personal injury.
CAUTION
Indicates a hazardous situation which, if
not avoided, could result in minor or
moderate personal injury.
SIGNAL WORD
Description of hazard
Consequence of ignoring the warning.
- Action to avoid the hazard.