Guldmann GH2 F - 13 Service and Lifetime; Service Inspection; Service Inspection, GH2 F

22
Lifting straps and cords for the travelling trolley must be replaced by the
Guldmann Service Team or by a qualied service tter in accordance with
Guldmann’s instructions.
Disposal of GH2 F, including batteries
Local and national regulations for environmentally responsible recycling must
be observed. Batteries should always be taken to approved recycling points.
1300 Service and lifetime
Lifetime
GH2 F has an expected lifetime of ten years provided that the service
inspections mentioned under point 13.01 are observed.
Replacing components
Batteries, printed circuit boards, lifting straps, and the locking and winding
mechanism on the travelling trolley must be replaced by the Guldmann
Service Team or by a qualied service tter in accordance with Guldmann’s
instructions.
1301 Service inspection
According to the international standard EN/ISO 10535 “Hoist for the transfer
of disabled persons - Requirements and test methods” a safety inspection of
the GH2 F must be performed at least one a year.
GH2 F and the Travelling trolley for GH2 F must be inspected by a qualied
service tter or by the Guldmann Service Team. Guldmann offers a service
agreement for GH2 F in connection with these inspections.
The service inspection includes a written report specifying what has been
inspected and replaced. Worn or defective components must be replaced
by new components from Guldmann. Spare parts drawings and lists can be
ordered from the manufacturer or distributor.
1302 Service inspection, GH2 F
1 Visual control of the hoist
• Check for wear, irregularities, or other types of damage to the hoist.
2 Testing the product as in normal use
• Check all hoist functions with and without loads
• Check that the emergency stop functions
• Check that the emergency lowering device functions
• Check that the green indicator lamps light up when the hoist is activated
• Check that the yellow charging indicator lights up when the hoist is being
recharged
• Check that the functions of the hand control are switched off when the sensor
on top of GH2 F is activated
© Guldmann US-882/12/2011 • # 900690_1.01
© Guldmann US-882/12/2011 • # 900690_1.01
© Guldmann US-882/12/2011 • # 900690_1.01 © Guldmann US-882/12/2011 • # 900690_1.01