9/29
PROSTART 430 - 610
• Go to the control seat of your vehicle. By ignitiating, you will activate the starter
function. If needed, reiterate the operation.
If the engine is not starting, restart a complete cycle (pre-charge, start).
Nb : if the engine is not starting after several trials, it means the battery needs a
complete charge or that there is another breakdown (mechanical, electrical, faulty
battery…)
• After the operation, unplug the prostart from the mains.
• Switch to STOP
• Remove the clamps
PROTECTIONS
Your machine has been designed with a maximum of protections:
- The charge clamps are fully isolated
- The polarity reversal and the short circuits do not cause any danger.
A double fuse (Ref : 054547) ensures the protection.
The replacement needs to be done manually.
- The protection against the transformer overloads or starting on the charge position is ensured by
a circuit breaker on the front panel of the machine. If it trips, a manual reactivation is needed.
- Thermal protection : your machine is protected by a thermostat
(cooling about 1/4h). A red indicator lights in case of overheating.
BATTERIES SULFATED OR DAMAGED
The machines PROSTART do not detect the damaged or sulphated batteries.
a) Your battery is highly damaged if in charge, the ammeter positioner quickly indicates very high
intensities. Your battery is definitively damaged.
b) In case of a sulfated battery : put the machine on the strongest charge mode (Prostart 430 :
200525Ah / Prostart 610 : 200600Ah) and regularly watch if the ammeter indicates a charging
current. As soon as the charging rises, position the selector on the charge adapted to the battery. If
nothing happens after 5 hours, your battery is definitively damaged.
ADVICE AND WARNINGS
• Your charger must be plugged to an outlet linked to the earth.
• The charger must be placed in such a way that the plug is always accessible.
• Use your starter-charger in a ventilated location and avoid sparks next to it.
• Do not use in any case to charge small batteries or non rechargeable batteries.
• Imperatively respect the indicated plugging order.
• Regularly check the starter-charger, and particularly the cable, plug and body, to detect any
damages. If the battery charger is damaged, it must not be used before being repaired.
• If the electricity supply cable is damaged, it must be replaced by the manufacturer, its after sales
service, or a person with the same qualifications to avoid any dangers.
• Do not open the charger. Any modifications not done by a technician from GYS will result in a
cancellation of the warranty.
• The charger must not be used as toy by young children, or used by young children or disabled
persons without any supervision.
• This product is to be recycled by selective collection. Do not throw in domestic garbage.
To Next Page
Loading...
Need help?
General
