TABLE OF CONTENTS
SECTION I: General Information
1-1 Specifications ................................................................... 1-2
1-2 Heater Component Parts (Model H3,H5,H6) ....................... 3
SECTION II: Installation of Heater
2-1 Location of Heater............................................................ 4-5
2-2 Hull Removal....................................................................... 6
2-3 Set-Up of Grates ................................................................. 7
2-4 Location of Plumbing & Electrical Lines............................... 8
2-5 Connection of Power to Heater............................................ 9
2-6 Wiring Diagram (H3,H5,H6)............................................... 10
2-7 Plumbing Instructions ........................................................ 11
2-8 Filling the Heater with Water......................................... 12-13
SECTION III: Connection to Central Heating/AC System
3-1 Connection to Central Unit
with existing Blower Coil.............................................. 14-16
3-2 Location of Heating Coil ............................................... 17-18
SECTION IV: Connection to Hydronic Heating Systems (Baseboard)
4-1 Connection to Hydronic System
with existing 24 Volt Transformer ................................ 19-20
4-2 Typical Diagram for Plumbing Hydronic System............... 21
SECTION V: Plumbing Options for Domestic Hot Water
5-1 Option 1 – Plate Heat Exchanger for Domestic Water
located at Hot Water Heater........................................ 22-23
5-2 Option 2 – Plate Heat Exchanger for Domestic Water
located at rear of Heater ................................................... 24
5-3 Automatic Water Fill (optional).......................................... 25
SECTION VI: Heater Operation
6-1 Firing the Heater................................................................ 26
6-2 Water Temperature .......................................................... 26
6-3 Wood Usage .................................................................... 26
6-4 Moisture in the Firebox..................................................... 26
6-5 Improper Burning ............................................................. 27
6-6 Ash Removal..................................................................... 27
(MODEL H3 H5 & H6)
vii
To Next Page
Loading...
