Harman Kardon AVR 1510 Service Manual

6
4
7
6
5
4
3
2
1
REVISION
SCHEMATIC DIAGRAM
SHEET
MODEL
DRAWING NODESIGN CHECK APPROVE
A
D
C
6
A
B
C
D
5 4 3 2 1
B
SEL
1A
1B
1Y
2A
2B
2Y
GND 3Y
3B
3A
4Y
4B
4A
ST
VCC
AVR151/230
2012.11.08
C.D.CS.K.SC.D.W
2012.11.08
VD DGND
VLC
AINR- AINR+ AINL+ AINL-
VA
AGND
AOUTB4-
AOUTB4+
AOUTA4+
AOUTA4-
AOUTB3-
AOUTB3+
AOUTA3+
AOUTA3-
AOUTB2-
AOUTB2+
AOUTA2+
AOUTA2-
AOUTB1- AOUTB1+ AOUTA1+ AOUTA1-
MUTEC
LPFLT
AGND VARX
RXP7 RXP6 RXP5 RXP4 RXP3 RXP2
RXP1
RXP0
TXP
VD
DGND
VLS
ADCIN2
ADCIN1
INT
RMCK
FILT+
VQ
RESET
SCL/CCLK CDIN/DATA AD0/CS
OMCK
CX_SDOUT
SDA/DOUT
SAI_SCLK
SAI_LRCK
SAI_SDOUT
CX_LRCK CX_SCLK
CRJ10DJ1R0T
HDMI SPDIF MODE : DIR MASTER
DIR MODE : DIR MASTER
ADC MODE : DSP MASTER
HDMI I2S MODE : HDMI MASTER
DAI_D3 DAI_D2 DAI_D1 DAI_D0
DIR_MCLK
SCP1_MOSI
SDTO2
BICK2
LRCK2
CX_SDIN4
CX_SDIN3
CX_SDIN2
CX_SDIN1
SDTO1
MCKO
VSS
DQ15 DQ14 VSSQ DQ13 DQ12
VDDQ
DQ11 DQ10 VSSQ
DQ9 DQ8
VDDQ
NC UDQM CLK CKE NC A9 A8 A7 A6 A5 A4
VSSVDD
A3 A2 A1 A0
A10/AP
BA
_CS
_RAS _CAS
_WE
LDQM
VDDQ
DQ7 DQ6
VSSQ
DQ5 DQ4
VDDQ
DQ3 DQ2
VSSQ
DQ1 DQ0
VDD
DAI1_DATA3/DSD3
VDDA(3.3V)
XTI
PLL_REF_RES
SCP1_CLK
GNDD6
RESET VDDIO6 EXT_CS1# GNDD5 EXT_OE#
VDD5 EXT_A15
SD_CS# SD_RAS#
SD_CAS# SD_WE# GNDIO5
VDDIO5
GNDD4
VDD4
EXT_CS2#
GNDIO4
SD_A12/EXT_A12
VDD3
SD_CLKEN
SD_CLKOUT
SD_DQM1
SD_CLKIN
GNDIO3
VDDIO3
SD_D15/EXT_D15
SD_D0/EXT_D0
EXT_WE#
SD_D1/EXT_D1
GNDIO2
VDDIO2
GNDD2
SD_DQM0
DBCK
DBDA
VDD2
GNDIO1
GNDD1
VDD1
TEST
DAO2_D3/XMTB
GPIO3/DDAC
XMCK
CEN/SUB/DAO02 FL/FR/DAO00
SL/SR/DAO01 SBL/SBR/DAO03
SD_D14/EXT_D14
SD_D13/EXT_D13
SD_D12/EXT_D12
SD_D11/EXT_D11
SD_D10/EXT_D10
SD_D8/EXT_D8
SD_D9/EXT_D9
SD_A11/EXT_A11
SD_A8/EXT_A8
SD_A9/EXT_A9
GNDD3
VDDIO4
SD_A7/EXT_A7
SD_A6/EXT_A6
SD_A5/EXT_A5
SD_A0/EXT_A0
SD_A1/EXT_A1
SD_A2/EXT_A2
SD_A4/EXT_A4
SD_A3/EXT_A3
SD_BA1/EXT_A14 SD_BA0/EXT_A13 SD_A10/EXT_A10 EXT_A16 EXT_A17 EXT_A19 EXT_A18
SD_D2/EXT_D2
SD_D3/EXT_D3
SD_D4/EXT_D4 SD_D5/EXT_D5 SD_D6/EXT_D6 SD_D7/EXT_D7
VDD8
GNDA
XTO
XTAL_OUT
SCP1_MISO/SDA
SCP1_CS
DAI1_DATA2/DSD2
DAI1_DATA1/DSD1
DAI1_DATA0/DSD0
DAI1_SCLK/DSD-CLK
DAI1_LRCK/DSD4
DAI2_SCLK
DAI2LRCK/PREQ
DAI2_DATA/DSD5
GNDIO6
PCP/SCP2_IRQ
A2/SCP2_MOSI
PCP/SCP2_CS
PCPDS/SCP2_CK
VDDIO7
GNDIO7
DAO2_D2
DAO2_D1/HS4
DAO_MCLK
DAO2_D0/HS3
DAO2_SCLK
DAO2_LRCLK
DAO1_D1/HS1 DAO1_D2/HS2
DAO1_D3/XMTA
DAO1_D0/HS0
DAO1_SCLK
DAO1_LRCLK
UART_CLK/EE_CS#
UART_TXD
UART_RXD
VDDIO1
GNDD8
VDDIO8
GNDIO8
DIGITAL AUDIO OUT DATA
VDD7
GNDD7
CS497** VDDIO * 8EA
CS497** VDD * 8EA
HDMI M_SW
H : B & HDMI on
L : A & HDMI off
GND
A8 A7 A6 A5 A4 A3 A2 A1
OE1VCC
OE2 Y1 Y2 Y3 Y4 Y5 Y6 Y7 Y8
ON : HIGH
SCP1_IRQ
SCP1_PCP_BSY
AS/SCP2_MISO
VDD6
CS SO WP
VSS
SISCKHOLD
VDD
REFGND
FROM JACK PCB
FROM HDMI RX AUDIO
TO HDMI TX AUDIO
<=> HDMI PART
ADC INPUT
XTAL_OUT
TXC
MULTI. LAB
ANAM
ISSUE
MP
27
6
(DSP_CODEC)
POSITION
12.07.26
00.00.00 00.00.00
CUP12503SCDZ
C1338
10V/22uF
C1337
0.1uF
C1339
0.1uF
C1340
16V/10uF
C1315
16V/10uF
C1325
1000P
C1326
0.022u
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
48474645444342414039383736353433
32
31
30
29
28
27
26
25
24
23
22
21
20
19
18
17
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
IC1301
CS42528-CQ
C1314
1000P
C1313
0.1uF
C1324
10V/22uF
C1323
0.1uF
C1322
0.1uF
C1321
100/16V
C1319
0.1uF
C1320
10/16V
C1317
10V/22uF
C1318
0.1uF
C1327
0.1uF
C1328
10V/22uF
C1362
0.1uF
C1361
0.1uF
C1360
0.1uF
C1359
0.1uF
C1358
0.1uF
C1357
0.1uF
49 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 32 31 30 29 28 27 26
25242322212019181716151413121110987654321
50
IC1308
CVIM12L16161A5TG2Q
L1304
CLZ9R005Z
C1354
10V/22uF
C1355
0.1uF
C1351
0.1uF
C1366
0.1uF
C1386
0.1uF
C1387
0.1uF
C1388
0.1uF
C1389
0.1uF
C1316
0.1uF
R1351
33
R1352 3.3K
R1353
3.3K
8765
4321
RN1304
33ohm (1005SIZE X 4)
8765 4321
RN1306
33ohm (1005SIZE X 4)
8765 4321
RN1307
33ohm (1005SIZE X 4)
8765 4321
RN1308
33ohm (1005SIZE X 4)
8765 4321
RN1309
33ohm (1005SIZE X 4)
8765 4321
RN1310
33ohm (1005SIZE X 4)
8765
4321
RN1311
33ohm (1005SIZE X 4)
8765
4321
RN1312
33ohm (1005SIZE X 4)
8765
4321
RN1303
33ohm (1005SIZE X 4)
C1367
0.1uF
C1368
0.1uF
C1371
0.1uF
C1370
0.1uF
C1369
0.1uF
C1365
0.1uF
C1364
0.1uF
C1372
0.1uF
C1373
0.1uF
C1377
0.1uF
C1378
0.1uF
C1379
0.1uF
C1376
0.1uF
C1375
0.1uF
C1374
0.1uF
8765 4321
RN1302
33ohm (1005SIZE X 4)
8765 4321
RN1301
33ohm (1005SIZE X 4)
12345678
9 10111213141516
IC1303
HVITC74VHC157FT
C1363
0.1uF
1
23
Q1301
C1356
0.1uF
C1350
0.1uF
8765
4321
IC1305
CVIMX25L8006EM2I-12G
1234567891011121314151617181920212223242526272829303132333435363738
39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60 61 62 63 64
65 66 67 68 69 70 71 72 73 74 75 76 77 78 79 80 81 82 83 84 85 86 87 88 89 90 91 92 93 94 95 96 97 98 99 100 101 102
103 104 105 106 107 108 109 110 111 112 113 114 115 116 117 118 119 120 121 122 123 124 125 126 127 128
IC1302
CVICS497024CVZ
R1333
82
8765 4321
RN1305
33ohm (1005SIZE X 4)
C1336
0.01uF
C1335 0.01uF C1334
0.01uF
C1333
0.01uF
C1332
0.01uF
C1331
0.01uF
C1330 0.01uF C1329
0.01uF
T1500
C1306
10/16V
C1307
0.1uF
C1312
10/16V
8765
4321
IC1306
NJM2115
C1311
150P
C1308
100P
C1309
2700P
C1310
0.1uF
C1303
0.1uF
C1302
2700P
C1301
100P
C1304
150P
8765
4321
IC1307
NJM2115
C1305
10/16V
IN
GND
OUT
13
2
1
2
3
IC1309
CVINJM2845DL118
C1344
16V/10uF
C1343
100/6.3V (OPEN)
L1302
CLZ9Z014Z
C1345
16V/10uF
L1303
CLZ9Z014Z
C1346
100/6.3V (OPEN)
C1347
16V/10uF
C1348
16V/10uF
C1349
16V/10uF
1 23
4
X1301
COX24576I120ST
C1352
12P
C1353
12P
12345678910
11 12 15 16 17 18 19 201413
IC1304
CVITC74VCX541FT
L1301
CLZ9Z014Z
C1341
10V/22uF
C1342
0.1uF
C1382
0.1uF
C1383
0.1uF
C1384
0.1uF
C1385
0.1uF
R1301
100
R1305
100
R1302
4.7K
R1304
4.7K
R1303
2.7K
R1306
2.7K
R1307
0
R1308
3.9K
R1309
4.7K
R1316
0
R1315
2.7K
R1313
2.7K
R1312
4.7K
R1311
4.7K
R1314
100
R1310
100
R1317
100
R1318
100
R1319
0
R1320
0
R1321
0
R1322
33
R1324
0
R1323
1.37K
R1329
1K
R1330
1K
R1325
0
R1326
10
R1328
0
R1331
0
R1327
33
R1338
3.3K
R1337
3.3K
R1334
100
R1340
3.3K
R1339
10K
R1341
10K
R1335 3.3K
R1336
3.3K
R1342
10K
R1343
10K
R1344
3.3K
R1345
10K
R1348
220
R1350
5.1K (1%)
R1349
33
R1347
0
R1346
1M
R1376
0
R1355
0
R1354
82
R1356
10K
R1358
10K
R1357
10K
R1359
33
R1360
33
R1361
33
R1362
33
R1363
33
R1375
1005 /1/16W / 82ohm
R1373
1005 /1/16W / 33ohm
R1372
1005 /1/16W / 33ohm
R1371
1005 /1/16W / 33ohm
R1367
10K
R1332
56
R1374
33
C1381
0.1uF
C1380
0.1uF
R1370
33ohm
R1369
33ohm
R1368
33ohm
R1365
0
R1364
0
R1366
0
DA7 DA6 DA5 DA4 DA3 DA2 DA1 DA0
DAO00 DAO02 DAO01 DAO03
DA15 DA13 DA12 DA11 DA10 DA9 DA8
+5VD_DSP
+3V3
+3V3
+5VD_DSP
+5VD_DSP
DIR_RESET
D_BL-
D_BR-
D_CT-
D_SW-
D_SL-
D_SR-
D_FL-
D_FR-
+5VD_DSP
DIR_CE
+3V3
+3V3
+3V3
+3V3
+3V3
+3V3
SCP1_CS
SCP1_IRQ
DIR_MISO
+3V3
DSP1_RESET
+1V8
D_FR+
D_FL+
D_SR+
D_SL+
D_SW+
D_CT+
D_BR+
D_BL+
+1V8
SCP1_BSY
+3V3
+1V8
SCP1_MISO
+3V3
+3V3
+1V8
+3V3
+1V8
+3V3
+1V8
+3V3
+3V3
+3V3
+3V3
+3V3
DSP_CODEC_CLK
DSP_CODEC_DATA
+1V8
+1V8
+3V3
+1V8
DA[0:50]
DAO[00:08]
DA[0:50]
DA[0:50]
HDMI_MCK_SW
+3V3
HDMI_TX_AUDIO_SW
+3V3
+3V3
+3V3
+3V3
DA15 DA14 DA13 DA12 DA11 DA10
DAO03
DAO02 DAO01 DAO00
DA16 DA17 DA18 DA19 DA20 DA21 DA22 DA23 DA24DA25
DA26 DA27 DA28 DA29 DA30 DA31 DA32 DA33 DA34 DA35
DA0
DA1
DA2
DA3
DA4
DA5
DA6
DA7
DA8
DA9
DA16
DA17
DA18
DA19
DA20
DA21
DA22
DA23
DA24
DA25
DA26
DA27
DA28
DA[0:50]
DA31 DA32 DA33 DA34 DA30 DA29
DSP1_DAO1_SCLK
DA35
DSP1_DAO1_LRCK
DSP1_DAO1_LRCK
DSP1_DAO1_SCLK
DSP1_MCLK
DA14
DSP1_MODE
+3V3
OPT1
OPT2
COAX1
MILAN_SPDIF
HDMI_RX_SPDIF
CODEC_MUTE
HDMI_RX_SD0
HDMI_RX_SD1
HDMI_RX_SD2
HDMI_RX_SD3
HDMI_RX_LRCK
HDMI_RX_SCK
HDMI_RX_MCLK
DSP_SPDIF
DSP_MCLK
DSP_DATA0
DSP_LRCK
DSP_SCLK
AD_RIN
AD_LIN
+5VD_DSP
+5VD_DSP
+1V8+3.3V_DC
AGND
AGND
AGND
AGND
AGND AGNDAGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
+3V3
+3.3V_DC
CHGND
DAO00
DSP1_DAO1_SCLK
DSP1_DAO1_LRCK
Harman Kardon
AVR 151 Service Manual
Page 129 of 131

Harman Kardon AVR 1510 Specifications

Audio Specifications

stereo power	75W per channel, two channels driven @ 6/8 ohms, 1kHz, <0.1% THD
multichannel power	75W per channel, two channels driven @ 6/8 ohms, 1kHz, <0.1% THD
input sensitivity/impedance	250mV/27k ohms
signal-to-noise ratio (IHF-A)	75dB
frequency response (@ 1W)	10Hz – 130kHz (+0dB/–3dB)
high instantaneous current capability (HCC)	±25 amps
slew rate	40V/sec

FM Tuner Specifications

frequency range	87.5MHz – 108.0MHz
usable sensitivity IHF	1.3µV/13.2dBf
signal-to-noise ratio (mono/stereo)	70dB/68dB
distortion (mono/stereo)	0.2%/0.3%
stereo separation	40dB @ 1kHz
selectivity (±400kHz)	70dB

AM Tuner Specifications

frequency range	520kHz – 1, 510kHz
signal-to-noise ratio	38dB
usable sensitivity (loop)	375µV
distortion (1kHz, 50% mod)	1.0%
selectivity (±10kHz)	30dB

Video Specifications

television format	NTSC
input level/impedance	1Vp-p/75 ohms
output level/impedance	1Vp-p/75 ohms
video frequency response (composite video)	10Hz – 8MHz (–3dB)
HDMI	Supports up to 4K x 2K

General Specifications

power requirement	120V AC / 60Hz
power consumption	<0.5W (standby); 410W maximum
dimensions (H x W x D)	4-3/4" x 17-5/16" x 11-13/16" (121mm x 440mm x 300mm)
weight	10 lb (4.6kg)