Hobart AM16 - Page 3

– 3 –
TABLE OF CONTENTS
GENERAL .....................................................................................4
INSTALLATION .................................................................................5
Unpacking ..................................................................................5
Installation Codes ............................................................................5
Location. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Corner Installation ............................................................................7
Plumbing Connections ........................................................................8
Water Requirements ......................................................................8
Water Supply Connection ..................................................................9
Drain Connection ........................................................................10
Venting Requirements ........................................................................ 11
Rate of Exhaust Flow Calculations ..........................................................11
Table A: Heat Dissipation ..................................................................12
Electrical Connections. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Voltage Adjustment (380 - 415 Volt Machines Only) .............................................14
Motor Rotation (480-Volt & 50-Hertz Machines Only) ............................................14
Equipment Connections ......................................................................15
Vent Fan Control ........................................................................15
Hobart Supplied Detergent, Rinse Aid, and Sanitizer Dispenser Installation ..............................15
Chemical Pump Programming (For Machines Equipped with Hobart Chemical Pumps) .................15
Chemical Pump Priming ..................................................................16
Testing Sanitizer (Chemical Sanitizing Machines) ...............................................17
Detergent and Rinse Aid Dispensers (For Machines with Chemical Pumps Supplied by Others) ..............17
Tubing Installation .......................................................................17
Detergent Dispenser .....................................................................18
Rinse Aid Dispenser. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Detergent, Rinse Aid, Sanitizer Dispensers — Equipment Connections .................................19
Detergent Dispenser .....................................................................19
Rinse Aid / Sanitizer Dispenser(s) ...........................................................20
OPERATION ..................................................................................21
Preparation ................................................................................21
Dishwashing ...............................................................................23
Recommended Condense Time (Based on Incoming Water Temp.) ....................................24
CLEANING ....................................................................................26
Delime Instructions ..........................................................................26
Manual Delime Process (Models AM16-BAS, AM16T-BAS, AM16VL-BAS, AM16VLT-BAS, AM16-SCB, and AM16VL-SCB) . 26
Auto Delime Process (Models AM16-ASR, AM16T-ASR, AM16VL-ADV, AM16VLT-ADV and AM16-SVLT). . . . . . . . . . . . . . . 27
Dos and Don'ts for Your New Hobart Warewasher ..................................................28
Manager Menu .............................................................................28
Manager Menu Parameters ...................................................................29
Hobart SmartConnect App ....................................................................31
Getting Connected ............................................................................... 31
MAINTENANCE ................................................................................33
Wash Arms ................................................................................33
Motor(s) ...................................................................................33
Chemical Pumps ............................................................................33
Cleaning Bafes on AM16VLT-BAS, AM16VLT-ADV and AM16-SVLT Models .............................33
TROUBLESHOOTING ...........................................................................35
Error Code Chart with Possible Solutions .........................................................35
Communication Module ......................................................................39
SERVICE .....................................................................................41
AM16 Expendable Parts ......................................................................41