HTP Everlast EVC080 - Page 14

lp-565 Rev. 002 Rel. 005 Date 11.19.18
14
T&P Relief Valve Maintenance Instructions:
• Annually: Certain naturally occuring mineral deposits may
adhere to the valve, blocking waterways and rendering the
valve inoperative. The T&P Relief Valve lever must be operated
to ensure the waterways are clear. If waterways are clear, hot
water will discharge from the valve. Take precautions to avoid
personal injury and property damage from contact with hot
water. Before operating lever, check to see that a discharge
line is connected to the valve, directing the ow of hot water
from the valve to a proper place of disposal.
• Replacement of the valve is required if no water ows when
the lever is operated. Turn the water heater o until the valve
is replaced.
• If water ows from the valve, drain a few gallons from the tank
to ensure the water ows freely.
• At least once every three years: To ensure that the T&P
valve has not been aected by corrosive water conditions
and that the valve and discharge line have not been altered
or tampered with illegally, relief valves should be inspected,
and replaced, if necessary, by a licensed plumbing contractor
or qualied service technician.
Failure to comply with these guidelines could result in failure
of relief valve operation, and possibly result in substantial
property damage, severe personal injury, or death.
9
10
14
16
1
3
4
5
6
7
7
8
8
8
10
11
12
13
15
9
16
# TRAP NOITPIRCSED#METI
1 JUNCTION BOX COVER (w/SCREWS) 6060P-983
610-P0547TUN NO-PILC2
300-P0606REPPU - TATSOMREHT3
400-P0606 REWOL TATSOMREHT4
5 THERMOSTAT PROTECTIVE COVER 6060P-634
6 THERMOSTAT PROTECTIVE COVER 6060P-636
781-P0606LENAP SSECCA7
600-P5706LENAP SSECCA - SWERCS8
659-P0606TEKCARB GNITNUOM9
939-P0606 W0003 -TIK TNEMELE CIRTCELE01
839-P0606W0054 - TIK TNEMELE CIRTCELE
739-P0606W0055 - TIK TNEMELE CIRTCELE
900-P0706 EVL
AV NIARD11
7301-P0606.LAG 511/08 - EBUT PID21
9101-P0606YLNO .LAG 001 - EBUT PID
8301-P0606PART TAEH/ELPPIN31
0071PTEVLAV FEILER ERUSSERP/PMET41
15 JUNCTION BOX COVER W/KNOCKOUTS (W/SCREWS) 6060P-982
569-P0606NOITALUSNI EVITCETORP61
LP-565-A
11/16/18
PARTS FOR UNITS WITH BOLT-ON T-STAT BRACKETS ONLY-NOT SHOWN
16 THERMOSTAT MOUNTING BRACKET-BOLT-ON 6060P-633
979-P0606RECAPS71
539-P0606STUN81
799-P0606REVOC EVITCETORP TNEMELE91
Figure 9 - Replacement Parts - Non-Simultaneous Operation