Hydro Tek CPS Series User Manual

INTRODUCTION ................................................................................................................ 2, 3, 4
Statement of Warranty, Emissions Statement
SAFETY WARNINGS......................................................................................................... 4, 5, 6
Electrical Precautions
Fire Precautions
Ventilation Precautions
Spray Injection Precautions
Personal Hazard Precautions
OPERATING INSTRUCTIONS ........................................................................................... 7, 8, 9
Before Start Up
Operation
Shut Down & Antifreeze Protection
SYSTEM INFORMATION
Power System ........................................................................................................... 9, 10
Electric Motor/Gasoline Engine/Diesel Engine
Power Transmission System – direct, & belt drive
Generator – auxiliary power, circuit breaker
Pumping System ..................................................................................................... 10, 11
Pump
Unloader and Pressure Relief Valve
Chemical Injection System
Water Supply
Heating System ....................................................................................................... 11, 12
Coil/Heat Exchanger System
Natural Gas / Propane Fired Burner
Diesel Fired Burner
Pressure Delivery System ............................................................................................. 13
Discharge Hose\Gun/Wand Assembly
Nozzles
Accessories ...................................................................................................... 13, 14, 15
Wet sandblaster, turbo nozzle, reels, Hydro Twister®, Wastewater recovery
TRAILERS ............................................................................................................................... 16
TROUBLESHOOTING GUIDE ..................................................................................... 17, 18, 19
BURNER TROUBLESHOOTING GUIDE ........................................................................... 20, 21
MAINTENANCE LOG .............................................................................................................. 22
NOZZLE CHART ...................................................................................................................... 23
SERVICE/MAINTENANCE SCHEDULE ..................................................................... Back cover
TRAILER REGISTRATION – CERTIFICATE OF ORIGIN ...................... Enclosed (If applicable)
TEST SPECIFICATIONS ............................................................................................... Enclosed
ENGINE SHEET ............................................................................................................. Enclosed
PARTS LIST / EXPLODED VIEW .................................................................................. Enclosed
WIRING DIAGRAMS ...................................................................................................... Enclosed
INSTALLATION INSTRUCTIONS .................................................................................. Enclosed
USE ONLY HYDRO TEK CERTIFIED ORIGINAL EQUIPMENT REPLACEMENT PARTS, FAILURE
TO DO SO COULD LEAD TO WARRANTY EXCLUSION AND SEVERE BODILY INJURY
TABLE OF CONTENTS 1

Hydro Tek CPS Series Specifications

General

Brand	Hydro Tek
Model	CPS Series
Category	Pressure Washer
Language	English