IAME Parilla Leopard TaG Series - Troubleshooting

MAN048ING42
19 TROUBLESHOOTING
Belowaresomecommonfaults,theirprobablecausesandsuggestedremedy:
FAULTS PROBABLECAUSES REMEDY
Starter w ill not crank when
turningthekeytoRUNposition
Badconnectionsonstartercables. Checkandtighten
Badgrounding Checkconnectionsandtighten.
Interruptiononfuse Replace 5A strip fuse, after
checking for eventual reversal of
batterypolarity.
Damagedcables Replace
Batteryconnectionsloose Checkandtighten
Batterydischarged Rechargebattery
Starterfailure Overhaulstarter
Relayfailure Replacerelay
Electronicbox
Apply to Authorized Service
Centers
Starter cranks but engine won’t
start when turning the key in
RUNposition
Badcableconnections Checkconnectors
Bad H.T. coil connection or coil
failure
Check/Replace
BadH.T.coilgrounding Checkgrounding
Electronicboxorignitionfailure Apply to Authorized Service
Centers
Wetsparkplug Replace
Malfunctiononinductionsystem Check status and connection on
fuelpipe
Replace gaskets and membranes
oncarburetor
Check reed petals. Replace if
necessary
Enginestartsbutitstopsaftera
few seconds when turning the
keyinRUNposition
Badcableconnections Checkstatorconnector
Electronicboxorstarterfailure Apply to Authorized Service
Centers
Bad carburetor adjustment
(Iscrew)
Check carburetor adjustment (see
sect.5)
Thestartercranksalsoafterthe
engineisrunning.
Electronicboxfailure Apply to Authorized Service
Centers
Roughidle
Badcarburetoradjustment
(Lscrew)
Check carburetor adjustment (see
sect.5)
Dropinengineperformance
Badcompression Checkpiston
Badcarburetoradjustment Check carburetor adjustement
(seesect.5)
Insufficientgasflow Checkfuelflowlinesandinletfilter
Dirtyinletsilencer Checkandclean
Burningsmell,smoke
Overheatingofclutch Checkclutch(seesect.11)
ClutchengagesattoohighRPM
Excessivewearoffrictionmaterial Checkclutch(seesect.11)
Exhausttoonoisy
Flexibledamaged Checkandreplaceifnecessary
Springsdamagedorlost
Insulatingstrapdamagedorlost
Damagedexhaustheader