IPC Lavamatic 46 - Technical Information; General Description; Parts of the Machine; Danger Zones

EN
TECHNICAL INFORMATION
General description
This machine is a scrubber dryer destined for sweeping, washing and drying at, horizontal, smooth or moderately
rough, even and obstacle-free oors.
The machine is intended for use in commercial applications, such as hotels, schools, hospitals, factories, shops
and o󰀩ces, or for hire.
The machine must only be used indoors.
It is available in both battery and mains powered versions to meet all running time requirements.
The scrubber dryer spreads a solution of water and detergent in the correct concentration on the oor and then
scrubs it to remove the dirt. By carefully choosing the detergent and brushes (or abrasive disks) from the wide
range of accessories available, the machine can be adapted to a wide range of combinations of types of oor
and dirt.
The machine incorporates a wet vacuuming system which dries the oor immediately after washing. The drying
action is produced by the suction motor, which generates a partial vacuum in the dirty water tank. The squeegee
connected to the tank collects the dirty water.
Parts of the machine
The main parts of the machine are as follows (g. A):
► the detergent tank (g. A, ref. 1): contains clean water;
► the dirty water tank (g. A, ref. 2): collects the dirty water picked up from the oor after washing;
► control panel (g. A, ref. 3);
► head assembly (g. A, ref. 4): the main element is the brush which distributes the detergent solution on
the oor and remove the dirt;
► squeegee assembly (g. A, ref. 5): wipes and dries the oor by collecting the water.
► Chem Dose tank (OPTIONAL) (g. P, ref. 1); contains the product added to the cleaning solution;
Danger zones
► Tank assembly: when using certain detergents, danger of irritation for eyes, skin, mucous membranes
and respiratory tract and of asphyxia. Danger represented by the dirt collected from the environment
(germs and chemical substances). Danger of crushing between the two tanks when the dirty water tank
is replaced on top of the detergent tank.
► Control panel: risk of injury from short circuits.
► Bottom of washing head: danger due to brush rotation.
► Rear wheels: danger of crushing between the wheel and chassis.
► Battery compartment (in the detergent tank): danger of short circuit between the battery poles and
presence of hydrogen during charging.
Accessories
DANGER
Before tting the accessories listed below, disconnect the plug from the mains power socket (mains
powered versions) or switch the machine o󰀨 (battery powered versions).
NOTICE
For a complete and up-to-date list of available accessories, contact an authorised dealer.
► Bristle brushes: for washing delicate oors and polishing;
► Polypropylene brushes: for normal oor washing;
► Tynex brushes: for removing accumulated stubborn dirt on resistant oors;
► Pad drive boards: enable the following disks to be used:
► Yellow disks: for washing and polishing marble and similar surfaces;
► Green disks: for washing resistant oors;
► Black disks: for thorough washing of resistant oors with stubborn dirt.
►► S.P.E. battery charger CBHD1S.P.E. battery charger CBHD1
21