MAIN CONTROL PANEL
ON
OFF
COUNTS
A. Pilot Light: Glows to indicate that electrical power
is turned on.
B.
Power On: Black rocker switch turns on power.
Pilot glows, motor runs, and belts move.
C.
Power Off: Red rocker switch turns off power.
Note: Opening the front or top guards shuts off
the machine. It must be restarted as above.
FUSE PANEL
D. Counter: Digital counter records the number of
sets that pass through the machine. A manual
reset button returns the counter to zero after each
job. The reset button can be locked to prevent
accidental reset.
E.
Stitch On/Off: Selector switch chooses mode of
operation: "On" for stitching jobs or "Off" for
folding without stitching.
A B C D E
ON STITCH OFF
POWER
Lift open the front guard. The fuse panel is located
on the left side wall. Use a small screw driver to
open each fuse holder.
A.
Main Fuse: Fuse protects entire machine. If this
fuse fails, power cannot be turned on. Replace
with 10 amp ceramic time-delay fuse, ISP
#RBM1239F.
B.
DC Fuse: Fuse protects transformer. If this fuse
fails, none of the 24VDC components will oper-
ate. Replace with proper .75 amp fuse, ISP
#RBM1267F.
MAIN DC
CAUTION:
For continued protection against
risk of fire, replace only with same
type and rating of fuse.
10A 250V .75A 250V
Stitch'n Fold
M AIN C O N T R O L PAN E L
Index Part Part Name Number
Number Number Required
Index Part Part Name Number
Number Number Required
1 RBM1712F Main Control Panel Decal 1
2 RBM1713F Bracket 1
3 RBM1324F Pan Hd Scr 10-32 x 1/2 2
4 RBM1714F Green Ilum. Momentary Switch 1
5 CG136 Red Rocker Switch (non-CE) 1
RBM1491F Emergency Stop (CE only) 1
RBM1492F Contact Block (CE only) 1
6 RBM1445F Counter 1
7 CG138 Black Selector Switch 1
8 RBM1726A Fuse Holder Decal 1
RBM1324F Pan Hd Scr 10-32 x 1/2 2
9 RBM1619F Fuse Holder Body 2
10 RBM1618F Fuse Holder Carrier 2
F U SES & TIM E R POTEN TIOM ETER
1, 2, 3
76
COUNTS
ON STITCH OFF
POWER
4
8
13, 14, 15, 16, 17
GATE TIMER
11 x 17
A3
8.5 x 11
5.5 x 8.5
A4, A5
PAPER SIZE:
MAIN DC
CAUTION:
For continued protection against
risk of fire, replace only with same
type and rating of fuse.
10A 250V .4A 250V
9, 10, 11 9, 10, 12
5
35* RBM1428F Rubber Grommet 6
36* RBM1640F Relay Bracket 1
37* RBM1324F Pan Hd Scr 10-32 x 1/2 2
38* RBM1355F Power Relay (1CR) 1
39* CB287E Rd Hd Scr 6-32 x 1/2 4
40* CB720 Nut 6-32 4
41* RBM1416F Timer - Single Shot 1
42* RBM1817F Cable Tie 1
43* RBM1417F Timer Socket 1
44* D32127F Rd Hd Scr 6-32 x 3/4 2
45* CB720 Nut 2
46* RBM1501A Transformer 1
47* RBM1323F Pan Hd Scr 8-32 x 1/2 2
RBM1352F.
RBM1350F.
.4
7
To Next Page