Kohler 12RES

Table of Contents, continued
Section 4 Troubleshooting ................................................................. 19
4.1 Introduction .......................................................... 19
4.2 Generator Set Troubleshooting .......................................... 19
4.3 Fault Codes .......................................................... 20
4.4 Controller Troubleshooting ............................................. 20
4.5 Battery Charger Troubleshooting ........................................ 20
Section 5 Wiring Diagrams ................................................................ 21
5.1 Specification Numbers ................................................. 21
5.2 Controller Wiring Diagram Reference .................................... 21
Section 6 Installation ...................................................................... 25
6.1 General .............................................................. 25
6.2 Weight ............................................................... 25
6.3 Generator Set Inspection ............................................... 25
6.4 Mounting ............................................................. 25
6.5 Exhaust Requirements ................................................. 25
6.6 Air Requirements ..................................................... 27
6.7 Power Supply ......................................................... 27
6.8 Fuel System .......................................................... 27
6.8.1 Fuel Supply .................................................. 27
6.8.2 Fuel Pipe Size ................................................ 28
6.8.3 Fuel Conversion .............................................. 28
6.9 Electrical Connections ................................................. 31
6.9.1 AC Load Lead Connections ..................................... 31
6.9.2 Remote Start Connection (optional) .............................. 32
6.9.3 Continuous Power Mode Jumper ................................ 32
6.9.4 Battery ....................................................... 33
6.9.5 Battery Charger ............................................... 34
6.10 Accessories .......................................................... 35
6.10.1 Common Fault and Run Relay Board ............................ 35
6.10.2 Carburetor Heater ............................................. 36
6.11 Controller Configuration ................................................ 37
6.11.1 System Configuration .......................................... 37
6.11.2 Advanced Configuration Mode .................................. 37
6.12 Prestart Installation Check .............................................. 37
6.13 Warranty Registration .................................................. 37
Appendix A Abbreviations .................................................................. A-1
Table of Contents TP-6195 1/04