TP-6772 2/14b 45Section 3 Scheduled Maintenance
Service Schedule—6--11EKOD/EKOZD & 5--9EFKOD/EFKOZD Models, continued
Perform Service at Intervals
Indicated (X)
Reference
Section
Daily
Every
50 Hrs.
or 1
Month
Every
250 Hrs.
or 3
Months
Every
500 Hrs.
or 6
Months
Every
1000 Hrs.
or Yearly
INTAKE/EXHAUST SYSTEM
Inspect the exhaust system components *[
3.5
X
(Before
operation)
Check the exhaust gas condition. If the exhaust is
blue or black, contact your local distributor/dealer
3.5
X
(During
operation)
Clean the exhaust/water mixing elbow *[
3.5 X
Inspect the crankcase breather system *[
Eng. S/M
X
(1500 hrs.)
Check the breather pipe for obstructions *[
X
Inspect the complete exhaust system *[ 2.2 X
ELECTRICAL SYSTEM
Keep the battery charged and in good condition w 3.8
X
(Before
operation)
Check and tighten the electrical connections * X
Clean the battery cables [
X
Check the starter motor [
(5000 hrs.)
ENGINE AND MOUNTING
Check for water, fuel, coolant, and oil leakage *[]
X
(After
operation)
Retighten any loose nuts and bolts *
X
(Before
operation)
Check the mounting bolts/vibromounts and tighten if
necessary *
X
Adjust the intake/exhaust valve clearance *[ Eng. S/M X
Check the compartment condition (fuel, oil, or water
leaks)
X
(Before
operation)
Replace the timing belt *[
Eng. S/M
X
(4000 hrs.)
Partial engine overhaul *[
Eng. S/M
X
(5000 hrs.)
Total engine overhaul *[
Eng. S/M
X
(10000 hrs.)
REMOTE START PANEL
Check the remote start panel operation, if equipped
X
(Break-in
period)
X
GENERATOR
Test run the generator set
X
(Weekly)
Blow dust out of the generator *[
3.1 X
6EKOD/5EFKOD Models: Clean the slip rings and
inspect the brushes *[
Gen. S/M X
* Requires removal of the sound shield door, if installed
[ Consult your local distributor/dealer for service
] Read the WARNING found at the beginning of the manual regarding moving parts
w Consult the battery manufacturer’s instructions
To Next Page
Loading...
