TP-5982 4/066 Safety Precautions and Instructions
Battery gases. Explosion can cause
severe injury or death. Battery gases
can cause an explosion. Do not smoke
or permit flames or sparks to occur near
a battery at any time, particularly when
it is charging. Do not dispose of a
battery in a fire. To prevent burns and
sparks that could cause an explosion,
avoid touching the battery terminals
with tools or other metal objects.
Remove all jewelry before servicing the
equipment. Discharge static electricity
from your body before touching
batteries by first touching a grounded
metal surface away from the battery. To
avoid sparks, do not disturb the battery
charger connections while the battery
is charging. Always turn the battery
charger off before disconnecting the
battery connections. Ventilate the
compartments containing batteries to
prevent accumulation of explosive
gases.
Battery short circuits. Explosion
can cause severe injury or death.
Short circuits can cause bodily injury
and/or equipment damage.
Disconnect the battery before
generator set installation or
maintenance. Remove all jewelry
before servicing the equipment. Use
tools with insulated handles. Remove
the negative (--) lead first when
disconnecting the battery. Reconnect
the negative (--) lead last when
reconnecting the battery. Never
connect the negative (--) battery cable
to the positive (+) connection terminal
of the starter solenoid. Do not test the
battery condition by shorting the
terminals together.
Engine Backfire/Flash
Fire
Fire.
Can cause severe injury or death.
Do not smoke or permit flames or
sparks near fuels or the fuel system.
WARNING
Servicing the backfire flame
arrester. A sudden backfire can
cause severe injury or death. Do not
operate the generator set with the
backfire flame arrester removed.
Combustible materials. A sudden
flash fire can cause severe injury or
death. Do not smoke or permit flames
or sparks near the generator set. Keep
the compartment and the generator set
clean and free of debris to minimize the
risk of fire. Catch fuels in an approved
container. Wipe up spilled fuels and
engine oil.
Combustible materials. A fire can
cause severe injury or death.
Generator set engine fuels and fuel
vapors are flammable and explosive.
Handle these materials carefully to
minimize the risk of fire or explosion.
Equip the compartment or nearby area
with a fully charged fire extinguisher.
Select a fire extinguisher rated ABC or
BC for electrical fires or as
recommended by the local fire code or
an authorized agency. Train all
personnel on fire extinguisher
operation and fire prevention
procedures.
Engine Fluids and
Chemical Products
Handling caustic engine fluids and
chemical products.
Can cause severe chemical burns,
nausea, fainting, or death.
Most chemicals such as used engine
oil, antifreeze/coolant, rustproofing
agent, inhibiting oil, degreasing
agent, spray paint, and adhesives are
hazardous to health. Read and follow
the user information found on the
packaging. Avoid inhalation and skin
contact. Use only in well-ventilated
areas and use a protective mask
when spraying. Store engine fluids
and chemical products in a locked
cabinet. Contact your local recycling
center for disposal information and
locations.
WARNING
Flammable engine solvents and
cleaners.
Can cause severe injury or death.
Do not smoke or permit flames or
sparks near flammable engine
solvents and cleaners. Read and
follow the user information found on
the packaging. Use only in well-
ventilated areas. Never use gasoline
or low flash-point solvents as
cleaning agents.
WARNING
Leaking or accumulated engine
fluids. A fire can cause severe injury
or death. Clean up engine fluids
including fuel, oil, grease, and coolant.
Determine the source of engine leaks
and correct before starting the
generator set. Keep the generator set
area clean and remove combustible
materials.
To Next Page
Loading...
Need help?
General
