TP-5982 4/06 7Safety Precautions and Instructions
Used engine oil. Contact with used
engine oil may cause severe skin
irritation. Repeated and prolonged
skin exposure may have other
health risks. Used engine oil is a
suspected carcinogen. Avoid contact
with skin. Thoroughly wash your hands
and nails with soap and water shortly
after handling used engine oil. Wash or
dispose of clothing or rags containing
used engine oil. Dispose of used
engine oil in a responsible manner.
Contact your local recycling center for
disposal information and locations.
Fire-damaged or burned O-rings
may cause the formation of
hydrofluoric acid. Contact with
hydrofluoric acid may cause severe
skin irritation and chemical burns.
O-rings and other fluoroelastomer
seals exposed to fire or temperatures
above 316_C (600_F) (i.e., during
welding) may decompose forming
hydrofluoric acid. Avoid inhalation or
skin contact. Do not incinerate O-rings.
Dispose of O-ring waste material in a
responsible manner.
Exhaust System
Carbon monoxide.
Can cause severe nausea,
fainting, or death.
The exhaust system must be
leakproof and routinely inspected.
WARNING
Carbon monoxide symptoms.
Carbon monoxide can cause severe
nausea, fainting, or death. Carbon
monoxide is a poisonous gas present in
exhaust gases. Carbon monoxide
poisoning symptoms include but are
not limited to the following:
D Light-headedness, dizziness
D Physical fatigue, weakness in
joints and muscles
D Sleepiness, mental fatigue,
inability to concentrate
or speak clearly, blurred vision
D Stomachache, vomiting, nausea
If experiencing any of these symptoms
and carbon monoxide poisoning is
possible, seek fresh air immediately
and remain active. Do not sit, lie down,
or fall asleep. Alert others to the
possibility of carbon monoxide
poisoning. Seek medical attention if
the condition of affected persons does
not improve within minutes of breathing
fresh air.
Inspecting the exhaust system.
Carbon monoxide can cause severe
nausea, fainting, or death. For the
safety of the craft’s occupants, install a
carbon monoxide detector. Consult the
boat builder or dealer for approved
detector location and installation.
Inspect the detector before each
generator set use. In addition to routine
exhaust system inspection, test the
carbon monoxide detector per the
manufacturer’s instructions and keep
the detector operational at all times.
Operating the generator set. Carbon
monoxide can cause severe nausea,
fainting, or death. Carbon monoxide
is an odorless, colorless, tasteless,
nonirritating gas that can cause death if
inhaled for even a short time. Use the
following precautions when installing
and operating the generator set. Do not
install the exhaust outlet whereexhaust
can be drawn in through portholes,
vents, or air conditioners. Avoid
overloading the craft. If the generator
set exhaust discharge outlet is near the
waterline, water could enter the
exhaust discharge outlet and close or
restrict the flow of exhaust. Never
operate the generator set without a
functioning carbon monoxide detector.
Be especially careful if operating the
generator set when moored or
anchored under calm conditions
because gases may accumulate. If
operating the generator set dockside,
moor the craft so that the exhaust
discharges on the lee side (the side
sheltered from the wind). Always be
aware of others, making sure your
exhaust is directed away from other
boats and buildings.
Fuel System
Explosive fuel vapors.
Can cause severe injury or death.
Use extreme care when handling,
storing, and using fuels.
WARNING
Explosion.
Gasoline vapors can cause
explosion and severe injury or
death.
Before starting the generator set,
operate the blower 4 minutes and
check the engine compartment for
gasoline vapors.
WARNING
To Next Page
Loading...
Need help?
General
