To Next Page
E
emily53Sep 3, 2025
How to fix water in the gear oil of my KTM 125 EXC EU?
- RreynoldsmichaelSep 3, 2025
If there's water in the gear oil of your KTM Motorcycle, it suggests a damaged shaft seal ring or water pump. Check these components for damage.
How to fix water in the gear oil of my KTM 125 EXC EU?
If there's water in the gear oil of your KTM Motorcycle, it suggests a damaged shaft seal ring or water pump. Check these components for damage.
Why is my KTM 125 EXC EU Motorcycle emitting white smoke from the exhaust?
If your KTM Motorcycle emits white smoke (steam) in the exhaust gas, it could be due to a damaged cylinder head or cylinder head gasket, so check them.
Why KTM Motorcycle engine has no idle?
If your KTM Motorcycle engine has no idle, a blocked idling jet could be the cause, so check/set the carburetor components. Another potential issue is distorted adjusting screws on the carburetor. Also, a defective spark plug can cause idling problems, so replace the spark plug. Finally, a defective ignition system may be the cause.
What to do if my KTM Motorcycle engine stalls or is popping into the carburetor?
If your KTM Motorcycle engine stalls or pops into the carburetor, it could be due to a lack of fuel. Ensure the fuel tap is in the ON position and refuel if necessary. Another cause could be the engine taking in bad air, so check the intake flange and carburetor for tightness. Also, make sure that the connector or ignition coil is not loose or oxidized, and clean the connector and treat it with contact spray if needed.
What to do if my KTM Motorcycle engine cannot be cranked with the electric starter?
If your KTM Motorcycle engine won't crank with the electric starter, several factors could be at play. It might be due to an operating error during the start procedure. Another cause could be a discharged battery, so you should recharge it and check the charging voltage, closed current, and alternator. Also, inspect the main fuse and replace it if it's blown. The starter relay or the starter motor itself could be faulty, requiring a check.
What to do if my KTM 125 EXC EU engine cannot be cranked?
If your KTM Motorcycle engine won't crank, it could be due to several reasons. You might not be following the correct start procedure. The battery could be discharged, requiring a recharge, voltage check, closed current check, and alternator inspection. The main fuse might be blown, so remove and reinstall it. Alternatively, the starter relay or motor could be faulty, requiring a check.
What causes a KTM Motorcycle engine not to speed up?
If your KTM Motorcycle engine does not speed up, a dirty or worn float needle causing the carburetor to run over could be the problem, so check/set the carburetor components. Loose carburetor jets can also prevent the engine from speeding up, so check/set the carburetor components. A fault in the ignition system may also be the cause.
Why does my KTM 125 EXC EU Motorcycle engine have too little power?
If your KTM Motorcycle engine has too little power, several factors could be responsible. A potential cause is an interrupted fuel feed, so check the fuel tank breather and clean the fuel tap, and check/set the carburetor components. A very dirty air filter can also restrict performance. Also, check the exhaust system for leaks or deformation, and replace the glass fiber yarn filling of the main silencer if needed. Lastly, inspect the diaphragm and reed valve housing for damage.
Why is my KTM Motorcycle engine overheating?
If your KTM Motorcycle engine is overheating, start by checking the coolant level and inspecting the cooling system for leaks. Ensure the radiator fins are clean to allow for proper cooling. Foam formation in the cooling system can also cause overheating, so the coolant should be drained and refilled. Inspect the cylinder head and cylinder head gasket for any damage. Finally, check for any bent radiator hoses.
Why my KTM Motorcycle engine turns over but won't start?
If your KTM Motorcycle engine turns over but doesn't start, it might be due to a few reasons. Ensure you are following the correct start procedure. If the motorcycle has been out of use for a while, the fuel in the float chamber might be old, consider emptying the carburetor float chamber. Check for any interruptions in the fuel feed by inspecting the fuel tank breather and cleaning the fuel tap. Also, a spark plug that's oily or wet could be the culprit, so clean, dry, or replace it. Adjust the plug gap to 0.60 mm (0.0236 in). Finally, check the connector or ignition coil and clean it with contact spray if it is loose or oxidized.
General| Brand | KTM |
|---|---|
| Model | 125 EXC EU |
| Category | Motorcycle |
| Language | English |
