KTM 690 Enduro R 2018

Other manuals for KTM 690 Enduro R 2018

Repair Manual311 pages

Questions and Answers

J
Jeffery BennettAug 17, 2025
What to do if KTM 690 Enduro R 2018 Motorcycle engine turns over but won't start?
- M
  Maria NewmanAug 17, 2025
  If your KTM Motorcycle engine turns but doesn't start, the following could be the reasons: * **Operating error:** Ensure you are following the correct start procedure. * **Blown fuse:** Replace fuse 3. * **Disconnected fuel hose:** Connect the plug-in connection of the fuel line. * **Fuel injection system defect:** Read out the fault memory using the KTM diagnostics tool.
J
Jesse DrakeAug 20, 2025
What to do if my KTM 690 Enduro R 2018 Motorcycle engine does not turn over?
- J
  James DiazAug 20, 2025
  If the engine of your KTM Motorcycle does not turn when you press the starter button, here are a few potential causes and solutions: * **Operating error:** Ensure you are following the correct start procedure. * **Discharged battery:** Recharge the battery and check the quiescent current. * **Blown fuses:** Replace fuses 1, 2, and 3, or the main fuse if it's burned out. * **No ground connection:** Inspect and verify the ground connection.
K
kristinchavezAug 22, 2025
Why does my KTM 690 Enduro R 2018 Motorcycle engine keep dying while riding?
- V
  Victoria CollinsAug 22, 2025
  If your KTM Motorcycle engine dies during the journey, it could be due to: * **Lack of fuel:** Refuel your motorcycle. * **Blown fuse:** Replace fuse 1, 2, or 3.
M
Matthew DurhamAug 25, 2025
Why is the ABS warning lamp on my KTM 690 Enduro R 2018 lighting up?
- C
  campbellkevinAug 26, 2025
  If the ABS warning lamp lights up on your KTM Motorcycle, it could be due to: * **Blown ABS fuse:** Replace the ABS fuses. * **Wheel speed difference:** Stop the vehicle, switch off the ignition, and then restart it. * **ABS malfunction:** In this case you should read out the ABS fault memory using the KTM diagnostics tool.
G
Gina KingAug 27, 2025
How to fix KTM Motorcycle engine overheating?
- K
  Kimberly OrtizAug 27, 2025
  If your KTM Motorcycle engine overheats, consider the following: * **Low coolant:** Check the cooling system for leaks and verify the coolant level. * **Dirty radiator fins:** Clean the radiator fins. * **Foam in cooling system:** Drain the coolant and then refill/bleed the cooling system. * **Damaged radiator hose:** Replace any buckled or damaged radiator hoses. * **Faulty thermostat:** Check the thermostat.
L
Loretta SkinnerAug 30, 2025
Why is my KTM Motorcycle using so much oil?
- E
  Ellen AndersonAug 30, 2025
  If your KTM Motorcycle has high oil consumption, check these: * **Bent engine vent hose:** Ensure the vent hose is routed without bends, or replace it if needed. * **High oil level:** Check the engine oil level.
T
Trevor DominguezSep 1, 2025
Why is the display blank on my KTM 690 Enduro R 2018 Motorcycle?
- W
  William RyanSep 1, 2025
  If the combination instrument on your KTM Motorcycle shows nothing in the display, it could be due to: * **Blown fuse:** Replace fuse 1 or 2 and set the clock.
E
Edward Brown DVMSep 4, 2025
Why does KTM Motorcycle engine only start when clutch is pulled?
- K
  Kayla MorganSep 4, 2025
  If your KTM Motorcycle engine only turns when the clutch lever is drawn, it is likely because: * **The vehicle is in gear:** Shift gear to neutral. * **The vehicle is in gear and the side stand is folded out:** Shift gear to neutral.
D
Dylan FullerSep 6, 2025
Why does the battery keep dying on my KTM 690 Enduro R 2018?
- D
  Dale ColonSep 6, 2025
  If the battery of your KTM Motorcycle is discharged, it might be because: * **Ignition left on:** The ignition was not switched off when the vehicle was parked, so recharge the battery. * **Alternator not charging:** The battery is not being charged by the alternator, so check the charging voltage and quiescent current.
M
Maria MccormickSep 9, 2025
Why are the headlight and parking light not working on my KTM 690 Enduro R 2018?
- C
  Cassie HintonSep 9, 2025
  If the headlight and parking light on your KTM Motorcycle are not working, it is likely due to: * **Blown fuse:** Replace fuse 6.

Summary

Safety and Operation

Intended Use and Misuse

Defines proper use and consequences of misuse for motorcycle operation.

Risk Levels and Warning Symbols

Explains hazard symbols and their associated risk levels for safety.

Safe Operation and Protective Clothing

Outlines essential safety measures for operating the motorcycle.

Vehicle Controls and Instrumentation

Handlebar Controls Overview

Identifies and explains various controls located on the handlebars.

Combination Instrument Functions

Details the display, indicators, and functions of the instrument cluster.

Pre-Ride and Riding Procedures

Preparing for First Use

Steps and advice for preparing the motorcycle before its initial rides.

Riding Instructions and Techniques

Guidance on starting, shifting, braking, and general riding practices.

Maintenance and Service

Service Schedule Overview

Outlines required and recommended maintenance tasks at various intervals.

Engine Oil and Filter Service

Procedures for changing engine oil and replacing the oil filter for optimal performance.

Brake System Maintenance

Guidance on checking and maintaining front and rear brake systems.

Chassis, Electrical, and Cooling Systems

Chassis Tuning and Adjustments

Instructions for adjusting suspension and handlebar positions for optimal handling.

Battery and Fuse Servicing

Procedures for battery removal, installation, recharging, and fuse replacement.

Cooling System Checks and Service

Steps for checking coolant levels and performing system maintenance.

Troubleshooting and Technical Data

Common Faults and Solutions

Identifies common problems and provides actionable solutions for troubleshooting.

Technical Specifications Overview

Provides detailed technical data including engine, chassis, and electrical system specifications.

KTM 690 Enduro R 2018 Specifications

General

Engine Type	Single cylinder, 4-stroke
Displacement	690 cc
Bore x Stroke	105 mm x 80 mm
Compression Ratio	12.7:1
Starter	Electric starter
Transmission	6-speed
Cooling	Liquid cooled
Front Suspension	WP USD Ø 48 mm
Rear Suspension	WP shock absorber with Pro-Lever linkage
Rear Brake	Brembo single-piston floating caliper, 240 mm disc
Front Tire	90/90-21
Rear Tire	140/80-18
Seat Height	910 mm
Ground Clearance	270 mm
Fuel Tank Capacity	13.5 liters
Dry Weight	146 kg
Fuel System	Electronic fuel injection (EFI)
Frame	Chromoly steel trellis frame
Front Brake	300 mm disc
ABS	Bosch
Front Wheel	21-inch
Rear Wheel	18-inch
Power	67 hp (49.5 kW) @ 7500 rpm
Wheelbase	1504 mm