Linde EVO 391-01 Series

To Next Page

LPG truck, CNG truck

riginal instructions

391-01 EVO® series

H14T, H16T, H16CNG,

H18T, H18CNG,

H20T, H20CNG

391 801 15 51 EN – 04/2018

Main Page

Table of Contents4
Introduction9
Your Truck10
Intended Use10
Impermissible Use12
Description of Use and Climatic Conditions12
Symbols Used13
Technical Description13
Hydraulic System14
Electrical System15
Receiving the Industrial Truck16
Customised Options16
Legal Requirements for Marketing17
Disposing of Components and Batteries18
Safety19
Safety Guidelines20
Safety Information20
Residual Risks21
Stability22
In the Case of Tip-Over22
Handling Consumables22
Competent Person23
Periodic Safety Inspection23
Safety Information on the LPG System24
Safety Guidelines for LPG (Extract)25
Safety Measures When Working on Ignition Systems27
Fit Attachments27
Mechanical Connection28
Hydraulic Connection29
Emergency Exit with Built-In Rear Window30
Emergency Lowering31
Towing33
Towing Procedure33
Overview37
Truck Overview38
Operating Devices39
Display Unit40
Switch Panel42
Labelling43
Nameplate43
Truck Numbers and Identification Plates45
Truck Configuration48
Operation49
Service Plan before Initial Commissioning50
Instructions for Running-In50
Pre-Shift Checks51
Regular Maintenance51
Standard Equipment52
Entering and Exiting the Truck52
Minimum Distance between Head and Overhead Guard52
Standard Driver's Seat and Comfort Driver's Seat53
Comfort Driver's Seat with Air Suspension55
Luxury Driver's Seat with Manual Weight Adjustment58
Luxury Driver's Seat with Automatic Weight Adjustment62
Adjusting the Armrest64
Adjusting the Steering Column65
Angle Adjustment65
Setting the Clock65
Opening the Gas Shut-Off Valve67
Seat Belt68
Unfastening the Seat Belt69
Starting and Stopping the Internal Combustion Engine (Dual-Pedal Operation)70
Switching off the Engine73
Closing the Gas Shut-Off Valve74
Driving (Dual-Pedal Operation)75
Starting and Stopping the Internal Combustion Engine (Single-Pedal Operation)79
Closing the Gas Shut-Off Valve84
Driving (Single-Pedal Operation)85
Reverse Travel86
Briefly Leaving the Truck88
Steering System89
Brake System89
Operating the Parking Brake90
Releasing the Parking Brake90
Signal Horn91
Joystick with Central Lever Operation92
Operating Attachments93
Joystick with Single Lever Operation98
Special Equipment104
Depressurisation104
Driver's Cabin104
Lighting105
Bluespot TM108
Truckspot TM109
Windscreen Wiper111
Window Heater114
Heating System, Air Conditioning115
Radio117
Access System Connect: (LFM)118
Keypad Input118
Adjusting the Driver's Seat with Rotating Device124
Lift Mast Positioning125
Camera System127
Sweeper Function127
Load Push Operation and Shovel Operation130
Switching off the Internal Combustion Engine Via the Seat Switch131
Linde Safety Pilot (LSP) Assistance System132
Buckle Monitoring on Seat Belt133
Overhead Guard with Optimised Visibility135
Reducing the Driving Speed Using a Radar Sensor (Speedassist)135
Working with a Load138
Load Capacity Diagram138
Additional Capacity Rating Plate for Attachments140
Adjusting the Fork Arm Distance142
Picking up a Load142
Determining Visibility Conditions When Driving with a Load144
Travelling with Load145
Setting down Loads145
Towing Device146
Before Leaving the Truck147
Loading/Transporting148
Removing/Attaching the Lift Mast148
Driving Without the Lift Mast148
Transporting the Truck Using a Lorry or Flat-Bed Trailer148
Servicing153
Safety Information Regarding Servicing Work154
Service Intervals154
Overview of the Filling Quantities and Set Values155
Recommendations for Consumables156
Lubricating Grease157
Service Plan159
Engine164
Checking the Engine Oil Level164
Gas System: Checking the Level165
Changing the LPG Cylinder166
Filling the LPG Tank (Special Equipment)169
Filling the CNG Tank (Special Equipment)171
Checking the CO Level in the Exhaust System174
CNG System: Checking the High-Pressure Relief Valve (Special Equipment)174
LPG System: Visual Inspection and Odour Inspection174
Check the Coolant Level175
Cleaning the Radiator and Checking the Radiator for Leak Tightness176
Check the Condition of the V-Ribbed Belt179
Check the Dust Discharge Valve181
Clean the Prefilter (Special Equipment)181
Checking the Leak Tightness of the Intake Lines and the Exhaust Lines181
Gearbox183
Checking and Adjusting the Side Stops on the Drive Axle183
Chassis, Bodywork and Fittings184
Cleaning the Truck184
Bonnet184
Closing the Bonnet186
Floorplate186
Maintaining the Heating System and Air Conditioning (Special Equipment)187
Checking the Condition and Function of the Seat Belt188
Checking and Lubricating the Bearing Points and Joints190
Topping up the Washer System Container (Special Equipment)191
Chassis Frame192
Wheel Change192
Tightening the Wheel Fastenings192
Checking the Wheels for Damage, Foreign Objects and Wear193
Checking the Tyre Pressure194
Checking the Condition of the Antistatic Belt195
Lubricating the Steering Axle195
Operating Devices196
Checking the Parking Brake for Correct Operation196
Checking the Pedal Group196
Electrics197
Checking the Condition of the Electric Connections and Checking that They Are Securely Attached197
Checking the Condition and Disposing of the Starter Battery197
Hydraulics199
Checking the Oil Level in the Hydraulic System199
Checking the Bleeder Valve on the Hydraulic Tank for Correct Function200
Checking the Hydraulic System for Leak Tightness201
Checking the Pre-Load of the Hose Lines202
Load Lift System203
Working on the Lift Mast and at the Front of the Truck203
Cleaning and Spraying the Lift Mast Chain205
Adjusting the Lift Mast Chain206
Checking the Fork Arms and Arm Safety Devices208
Checking and Lubricating the Sideshift (Special Equipment)209
Checking and Lubricating the Fork Prong Positioner (Special Equipment)210
Self-Help212
Opening the Cover to the Electrical System212
Fuses for Basic Equipment and for Special Equipment213
Main Fuses in the Engine Compartment214
Diagnostic Connector215
Fault Displays216
Malfunctions, Causes and Remedies: Gas Engine220
Malfunctions, Causes, Remedies: Ultrasonic Sensor222
Malfunctions, Causes and Remedies: Hydraulic System223
Jump Start225
Switching off227
Placing the Forklift Truck into Storage227
Disposal of Old Trucks228
Technical Data229
Overview of Dimensions230
Overview of Type Sheets (LPG)231
Overview of Type Sheets (CNG)236
Lift Mast Data Model 181240
Tyre Variants and Rim Sizes241
Noise Emission Values242
Characteristic Values for Body Vibrations242

Brand	Linde
Model	EVO 391-01 Series
Category	Forklifts
Language	English

Linde EVO 391-01 Series - User Manual

Table of Contents

Linde EVO 391-01 Series Specifications

Related product manuals