Rev: 10.05.18
Page 2
CCD-0001632
Product Information
NOTE: This information was obtained from Kwikee® manual 3010002262 Rev 0A dated September 2009.
This manual does not apply and should not be used as a reference to previous versions of the
Kwikee® electric step.
This manual has been provided to assist you with the operation, maintenance, and troubleshooting of the Kwikee®
Electric Step equipped for use with a step lockout switch, control unit and permanent magnet motor.
The control unit is essentially a current sensor as well as a switching device. When the motor assembly moves the
step tread to its extended position, or stops moving because of an obstruction such as a curb or the binding of
a damaged or bent step frame, the motor draws a higher amount of current. The control unit ‘senses’ the higher
current draw and shuts off the power to the motor.
TABLE OF CONTENTS
Safety Information 2
Product Information 2
General Service Notes 3
Prior To Operation 3
Operation 4
Step With Control Unit 4
Troubleshooting 5
Step Test Procedure 5
Testing The Motor 7
Disconnect The 2-Way Connector Between The Step Motor And The Control Unit 7
Testing The 4-Way Connector 7
Maintenance 9
Step Motor Assembly Lubrication 9
Maintenance In A Salt Environment 9
Safety Information
The “WARNING” symbol above is a sign that an installation procedure has a safety risk involved
and may cause death or serious injury if not performed safely and within the parameters set forth
in this manual. Always wear eye protection when performing this installation procedure. Other
safety equipment to consider would be hearing protection, gloves, and possibly a full face shield,
depending on the nature of the installation procedure.
The coach MUST be supported per manufacturer's specications before working underneath.
Failure to do so may result in death or serious injury.
Failure to act in accordance with the following may result in death or serious personal injury. Read
all operating instructions rst before using your Kwikee® Electric Step.
Moving parts can pinch, crush or cut. Keep clear and use caution.
To Next Page
Loading...
Need help?
General
