Lubrication
ERVICE
ENGINE.
Check oil level
and
top up if neccs ary.
THROTTLE.
Lubricate
throttle
control linkage, cable and accelerator pedal fulcrum.
REAR
AXLE.
Check oil level, and top up if nee ary.
GEARBOX.
Check oil level, and top up if ncccs ary.
FRONT
SUSPENSION
(6 niPPleS)} Give three or f
our
stro ke. with a grease gun.
PROPELLER
SHAFT
(1 nippl e)
WIRE
WHEELS
ONLY.
Gre
ase whc I an d hub splines.
FRICTION
POINTS.
Spray lubricant on all fri ·ti n p iin t».
TE:
Ensure
that
the vehicle is standing on a level surface when checking the oil levels.
EKLY
I)
ENGINE.
Check oil level
and
top up if nece ary.
A'SERVICE
2)
ENGINE.
Drain
and
refill with new oil.
4)
THROTTLE.
Lubricate
throttle
control linkage, cable
and
accelerator pedal fulcrum.
()
CARBURETTER.
Top
up carburetter piston damper.
6)
REAR
AXLE.
Check oil level, and top up if necessary.
(7)
GEARBOX.
Check oil level,
and
top up if necessary.
)
FRONT
SUSPENSION
(6 nipples),,- . .
f
GIve three or four strokes WIth a grease gun.
10)
PROPELLER
SHAFT
(l
nipple)
II)
WIRE
WHEELS.
Lubricate wire wheel and hub splines.
LOCKS,
HINGES
AND
LINKAGES.
Lubricate all
door,
bonnet, luggage
compartment
locks
and
hinges (not steering lock).
FRICTION
POINTS.
Spray lubricant on all friction points.
,
SERVICE
)
ENGINE.
Drain
and
refill with new oil.
)
ENGINE
OIL
FILTER.
Remove disposahl \ .artrid 'C, fit new.
4)
THROTTLE.
Lubricate throttle cont rol linka c, cab le and accelerator pedal fulcrum.
)
REAR
AXLE.
Check oil level, and top
LIp
if I cccssary.
(7)
GEARBO
'X. Check oil level, and top 1Ip if necessary.
( )
FRONT
SUSPENSION
(6 niPPleS)} . .
Give three
I' f
our
strokes WIth a grease gun.
I )
PROPELLER
SHAFT
(1 nipple)
II
)
WIRE
WHEELS
ONLY.
Grease wheel and hub splines.
LOCKS,
HINGES
AND
LINKAG
ES. Lubricate all
door
, bonnet, luggage
compartm
ent locks
(7 )
U.t:AKtlU
'X. Check
all
level, and top up II nc .cssary.
)
FRONT
SUSPENSION
(6 niPPleS)} . .
Give three or f
our
strokes WIth a grease gun.
I )
PROPELLER
SHAFT
(l
nipple)
II
)
WIRE
WHEELS
ONLY.
Grease wheel and hu b splines.
LOCKS,
HINGES
AND
LINKAG
ES. Lubricate a ll d
oor
, bonnet, luggage
compartm
ent locks
and
hinges (not steering lock); and the hand brake rnechanical linkage.
FRICTION
POINTS.
Spray lubricant on all friction points.
,
'AND
'E'
SERVICES
arry
out
a
'C'
service in
addition
to the followin g item (5)
and
(12).
5)
CARBURETTERS.
Top
up carburetter piston damper.
)
STEERING.
Lubricate steering rack (every 37,500 miles).
I )
DISTRIBUTOR.
Lubricate all parts as necessary.
8
1
6
8
1
11\
II
To Next Page
Loading...
