CONTENTS-3
CONTENTS
Periodic Maintenance Chart for
Emergency Engine .............................7-5
Chapter 8
PERIODIC INSPECTION AND
MAINTENANCE PROCEDURES
Basic Engine........................................8-1
Engine External - Inspect................................. 8-1
Belt and Belt Tension - Inspect and Adjust ...... 8-2
Damper - Inspect.............................................. 8-5
Fuel System.........................................8-7
Fuel System - Inspect ...................................... 8-7
Fuel Tank - Clean............................................. 8-7
Fuel Tank - Drain Water................................... 8-7
Oil-water Separator - Drain Water.................... 8-8
Oil-water Separator Element - Replace ........... 8-8
Gauze Filter - Clean ......................................... 8-9
Fuel Filter - Replace....................................... 8-10
Fuel Control Link Ball Joint - Inspect.............. 8-11
Fuel Pipe - Inspect ......................................... 8-12
Lubrication System............................8-13
Engine Oil, Oil Filter and Bypass Oil Filter -
Replace.......................................................... 8-13
Fuel and Water Ingress In Engine Oil -
Inspect .......................................................... 8-16
Oil Pipe - Inspect............................................ 8-16
Cooling System .................................8-17
Coolant - Change ........................................... 8-17
Inlet and Exhaust Systems................8-21
Turbocharger - Inspect................................... 8-21
Pre-cleaner - Clean, Inspect and Replace ..... 8-21
Air Cleaner Element - Clean, Check and
Replace ......................................................... 8-22
Electrical System...............................8-24
Starter - Inspect.............................................. 8-26
Alternator - Inspect......................................... 8-26
Chapter 9
LONG-TERM STORAGE
Storing Engine in an Inoperable
Condition for 3 Months up to 1 Year....9-1
Preparation for Storage.................................... 9-1
Maintenance During Storage ........................... 9-2
When Using Engine After Storage ................... 9-2
Storing Engine in an Operable
Condition ............................................9-2
Operating Engine for Maintenance .................. 9-2
Chapter 10
TRANSPORTATION
Lifting Engine .................................... 10-1
Chapter 11
TROUBLESHOOTING
General Precautions ......................... 11-1
Contact a Dealer of Mitsubishi Heavy Industries,
Ltd. for Repair Service ................................... 11-1
Considerations Before Proceeding with
Corrective Action ............................................ 11-1
Cautions Against Contamination .................... 11-1
Cautions Regarding Parts Handling ............... 11-1
Safety Work.................................................... 11-1
Cases of Problems, and Probable
Causes and Solutions ....................... 11-2
The Starter Does not Crank or Cranks Slowly,
Resulting in Start Failure................................ 11-2
Starter Cranks, but Engine Does Not Start .... 11-3
Output Decrease ............................................ 11-4
Exhaust Smoke is White or Blue.................... 11-5
Exhaust Smoke is Black or Charcoal ............. 11-6
Fuel Consumption is High .............................. 11-7
Engine Oil Consumption is High .................... 11-8
Overheating.................................................... 11-9
Low Engine Oil Pressure.............................. 11-10
When Fuel has Run Out ................. 11-10
Chapter 12
MAIN SPECIFICATIONS
Main Specifications ........................... 12-1
To Next Page
Loading...
