Mitsubishi S16R2-PTAW - Page 12

CONTENTS
CONTENTS-4
List of Illustration
Fig. 1-1 Warning Labels .................................. 1-11
Fig. 2-1 Engine Front View ................................ 2-1
Fig. 2-2 Engine Rear View................................. 2-1
Fig. 2-3 Engine Left View .................................. 2-2
Fig. 2-4 Engine Right View ................................ 2-2
Fig. 2-5 Manual Stop Lever ............................... 2-3
Fig. 2-6 Stop Solenoid ....................................... 2-3
Fig. 2-7 Revolution Detection Pickup ................ 2-4
Fig. 2-8 Thermo Switch ..................................... 2-5
Fig. 2-9 Oil Filter Differential Pressure Alarm
Switch .................................................. 2-5
Fig. 2-10 Air Cleaner Indicator ............................ 2-5
Fig. 2-11 Manual Turning Gear Position
(While Engine is Running).................... 2-6
Fig. 2-12 Manual Turning Gear Position
(When Pushing Shaft in) ...................... 2-6
Fig. 2-13 Manual Turning Gear Position
(When Turning Shaft) ........................... 2-6
Fig. 3-1 Priming Pump - Operate ...................... 3-2
Fig. 3-2 Fuel Filter - Bleed Air............................ 3-2
Fig. 3-3 Fuel Injection Pump - Bleed Air............ 3-2
Fig. 3-4 Priming Pump Tightening Method ........ 3-3
Fig. 3-5 Priming Pump Head Packing ............... 3-3
Fig. 3-6 Oil Filler and Oil Level Gauge .............. 3-4
Fig. 3-7 Pouring Engine Oil on Valve Mechanisms
and Chamber........................................ 3-4
Fig. 3-8 Coolant Drain Cock (Engine)................ 3-5
Fig. 3-9 Coolant Drain Cock
(Engine water pump) ............................ 3-5
Fig. 3-10 Air Vent Plug (Engine Cooling System) 3-5
Fig. 3-11 Coolant Drain Cock (Air Cooler)........... 3-6
Fig. 3-12 Coolant Drain Cock
(Air Cooler water pump) ....................... 3-6
Fig. 3-13 Battery Electrolyte Level - Inspect........ 3-7
Fig. 3-14 Specific Gravity of Battery Electrolyte -
Check ................................................... 3-8
Fig. 3-15 Fuel Tank - Drain Water ..................... 3-11
Fig. 3-16 Check Fuel Control Link ..................... 3-11
Fig. 3-17 Oil Filler and Oil Level Gauge ............ 3-12
Fig. 3-18 Air Cleaner - Check for Clogging ....... 3-13
Fig. 3-19 Thermo Label of Damper ....................3-13
Fig. 3-20 Manual Stop Lever ..............................3-16
Fig. 5-1 Engine Oil Grade...................................5-1
Fig. 5-2 Selection of Oil Viscosity.......................5-3
Fig. 6-1 GLASSY - LLC ......................................6-1
Fig. 6-2 Coolant Freezing Temperature
(GLASSY, PG GLASSY).......................6-7
Fig. 8-1 Belt Tension (Alternator Side) - Adjust ..8-2
Fig. 8-2 Belt Tension (Air Cooler water pump Side) -
Adjust ....................................................8-2
Fig. 8-3 Damper - Check Visually.......................8-5
Fig. 8-4 Damper Temperature Control ...............8-6
Fig. 8-5 Fuel Tank - Drain Water ........................8-7
Fig. 8-6 Water Separator - Drain Water..............8-8
Fig. 8-7 Water Separator Element - Replace .....8-8
Fig. 8-8 Gauze Filter - Clean ..............................8-9
Fig. 8-9 Fuel Filter - Replace ............................8-10
Fig. 8-10 Fuel Filter ............................................8-10
Fig. 8-11 Ball Joints Looseness - Inspect...........8-11
Fig. 8-12 Fuel Control Link - Remove.................8-11
Fig. 8-13 High Pressure Fuel Injection Pipe and
Clamp Seat - Inspect and Replace ....8-12
Fig. 8-14 Low Pressure Fuel Pipe and Clip -
Inspect.................................................8-12
Fig. 8-15 Oil Filter and Bypass Oil Filter -
Replace ...............................................8-14
Fig. 8-16 Oil Filter...............................................8-14
Fig. 8-17 Oil Filler and Oil Level Gauge .............8-15
Fig. 8-18 Oil Pipe and Clip - Inspect and
Replace ...............................................8-16
Fig. 8-19 radiator Cap .......................................8-17
Fig. 8-20 Coolant Drain Cock (Engine)...............8-18
Fig. 8-21 Coolant Drain Cock (water pump) .......8-18
Fig. 8-22 Coolant Drain Cock (Engine)...............8-19
Fig. 8-23 Coolant Drain Cock
(Engine water pump)...........................8-19
Fig. 8-24 Air Vent Plug (Engine Cooling
System) ...............................................8-19
Fig. 8-25 Coolant Drain Cock (Air Cooler)..........8-20
Fig. 8-26 Coolant Drain Cock
(Air Cooler water pump) ......................8-20