Mitsubishi S6R2 User Manual

CONTENTS-3
CONTENTS
Periodic Maintenance Chart for
Regular Use Engine ............................7-3
Periodic Maintenance Chart for
Emergency Engine..............................7-5
Periodic Maintenance Chart for
General Purpose Engine.....................7-9
Chapter 8
PERIODIC INSPECTION AND
MAINTENANCE PROCEDURES
Basic Engine........................................8-1
Engine External - Inspect................................. 8-1
Belt and Belt Tension - Inspect and Adjust...... 8-2
Damper - Inspect.............................................. 8-4
Fuel System.........................................8-6
Fuel System - Inspect ...................................... 8-6
Fuel Tank - Clean............................................. 8-6
Fuel Tank - Drain Water................................... 8-6
Water Separator - Drain Water ........................ 8-7
Water Separator Element - Replace ................ 8-7
Gauze Filter - Clean......................................... 8-8
Fuel Filter - Replace......................................... 8-9
Fuel Control Link Ball Joint - Inspect.............. 8-10
Fuel Pipe - Inspect ......................................... 8-11
Lubricating System............................8-12
Engine Oil, Oil Filter and Bypass Oil Filter
- Replace........................................................ 8-12
Engine Oil for Mixing of Fuel and Water
- Inspect ......................................................... 8-14
Governor Oil Filter - Change.......................... 8-15
Oil Pipe - Inspect............................................ 8-15
Cooling System .................................8-16
Coolant - Change........................................... 8-16
Radiator Fins - Check and Clean................... 8-18
Inlet and Exhaust Systems................8-19
Turbocharger - Inspect................................... 8-19
Exhaust Muffler - Drain Water........................ 8-19
Air Cleaner - Check for Clogging ................... 8-20
Air Cleaner Element - Clean, Check and
Replace.......................................................... 8-21
Electrical System...............................8-23
Starter - Inspect.............................................. 8-24
Alternator - Inspect......................................... 8-24
Air Starter System .............................8-25
Air Strainer - Drain Water and Clean ............. 8-25
Air Tank - Drain Water ................................... 8-25
Air Tank - Inspect Safety Valve Operation ..... 8-26
Chapter 9
LONG-TERM STORAGE
Storing the Engine in an Inoperable
Condition for 3 Months or More .......... 9-1
Preparation for Storage....................................9-1
Maintenance During Storage ........................... 9-1
Using the Engine After Storage........................9-2
Storing the Engine in an Operable
Condition for 3 Months or More .......... 9-2
Operating the Engine for Maintenance ............9-2
Chapter 10
TRANSPORTATION
Lifting the Engine .............................. 10-1
Chapter 11
TROUBLESHOOTING
General Precautions ......................... 11-1
Contact a Dealer of Mitsubishi Heavy Industries,
Ltd. for Repair Service ................................... 11-1
Considerations Before Work .......................... 11-1
Cautions Against Contamination.................... 11-1
Cautions Regarding Parts Handling............... 11-1
Safety Work.................................................... 11-1
Case of Problems, and Conceivable
Causes and Remedies......................11-2
The Starter Does Not Crank or Cranks Slowly,
Resulting in Start Failure................................ 11-2
The Starter Cranks, but the Engine Does Not
Start................................................................ 11-3
Output Decrease............................................ 11-4
Exhaust Smoke is White or Blue.................... 11-5
Exhaust Smoke is Black or Charcoal ............. 11-6
Fuel Consumption is High .............................. 11-7
Engine Oil Consumption is High .................... 11-8
Overheating.................................................... 11-9
Low Engine Oil Pressure................................ 11-9
When Fuel has Run Out ................. 11-10
Chapter 12
MAIN SPECIFICATIONS
Main Specifications...........................12-1

Mitsubishi S6R2 Specifications

General

Brand	Mitsubishi
Model	S6R2
Category	Engine
Language	English