Monterey M3 - Maintenance Log

168 pages

Save Page as PDF

To Next Page

To Next Page

To Previous Page

To Previous Page

Loading...

144

MONTEREY

BOATS

Maintenance Log

Hours

Date Dealer

Service/Repairs

Table of Contents

Default Chapter2
- Welcome2
- Table of Contents4
- Safety Information8
- Boat Information9
- M3 Specifications10
- M5 Specifications11
- M3 Certifications & Specifications12
- M5 Certifications & Specifications13
- Introduction and Important Information14
- Introduction and Important Information15
- Owner's / Operator's Information16
- New Boat Delivery17
Chapter 1 SAFETY EQUIPMENT18
- General18
- Engine Alarm18
- Neutral Safety Switch18
- Required Safety Equipment19
- Bilge and Fuel Fires20
- Fire Port20
- Automatic Fire Extinguishing System (Optional)21
- First Aid22
- Additional Safety Equipment22
- Caution and Warning Labels24
Chapter 2 OPERATION26
- General26
- Rules of the Road26
- Pre-Cruise Check29
- Operating Your Boat30
- Docking, Anchoring and Mooring31
- Controls, Steering, or Propulsion System Failure33
- Collision33
- Grounding, Towing and Rendering Assistance33
- Flooding or Capsizing34
- Fishing34
- Water Skiing and Wakeboarding34
- Teak Surfing36
- Man Overboard37
- Trash Disposal37
- Trailering Your Boat37
Chapter 3 PROPULSION SYSTEM40
- General40
- Drive Systems40
- Engine Exhaust System41
- Engine Cooling System41
- Propellers42
- Performance Issues and Propellers42
- Helm and Engine Instrumentation43
- Hour Meter44
Chapter 4 4.1 General46
- Outdrive Power Tilt and Trim50
- Steering System51
- Trim Tabs (Optional M3 & M5)51
- Control Systems Maintenance52
Helm Control Systems46
- General46
- Engine Throttle and Shift Controls46
Chapter 554
- Gasoline Fuel System55
- Fueling Instructions55
- Fuel System Maintenance56
Fuel System54
- General54
Chapter 6 ELECTRICAL SYSTEM58
- General58
- 12-Volt System58
- Wet Sounds Audio System (Optional M5 and M3)65
- 120-Volt Battery Charging System (Optional M3 and M5)67
- Bonding System68
- Electrical System Maintenance68
Chapter 7 7.1 General70
- Fresh Water System Maintenance71
Fresh Water System70
- General70
- Fresh Water System Operation70
Chapter 8 BALLAST SYSTEM (MSX)75
- Ballast System Maintenance75
Chapter 9 DRAINAGE SYSTEMS78
- General78
- Bilge Drainage78
- Cockpit and Deck Drains79
- Grey Water System (Optional M5 Models Only)79
- Wakeboard Tower Drains (MSX Models)80
- Drainage System Maintenance80
Chapter 10 VENTILATION SYSTEM82
- Engine Compartment Ventilation82
- VENTILATION SYSTEM 10.1 Engine Compartment Ventilation82
- Maintenance84
Chapter 11 11.1 Deck86
- Hull88
- Cockpit90
  - Engine Access91
  - Cockpit Table95
- Bimini Top and Optional Canvas101
- Arch & Tower (Optional)101
- Wakeboard Tower & Hardtop (MSX Models)103
- Aftermarket Hardtop, Wakeboard Tower or Arch105
Exterior Equipment86
- Deck86
Chapter 12 INTERIOR EQUIPMENT106
- Head Compartment106
- Marine Head Systems106
Chapter 13 13.1 Exterior Hull and Deck110
- Upholstery, Canvas and Enclosures115
- Cabin Interior119
- Bilge and Engine Compartment120
- Drainage System120
Routine Maintenance110
- Exterior Hull and Deck110
Chapter 14 SEASONAL MAINTENANCE122
- Lay-Up and Storage122
- Winterizing124
  - Portable Head124
  - Marine Toilet124
- Recommissioning126
Appendix A128
- M5 Standard Battery Wiring128
- Standard Battery Switch Panel129
- Volvo Evc-D Diagrams130
- M5 MSX Harness131
- M5 MSX Tower Harness132
- Hatch Harness133
- Hull Harness134
- Deck Harness135
- M5 Stereo Upgrade Harness136
- M5 Stereo Panel137
- M5 MSX Wet Sounds Installation138
- Mb Quart Amp Settings139
- DC Ipod Adapters140
Appendix B142
- General Maintenance Schedule and Log142
- Maintenance Log143
Appendix C: Float Plan146
Appendix D148
- Boating Accident Report148
Appendix E: Glossary of Terms152
- Troubleshooting Guide158
Appendix F: Troubleshooting Guide158
Appendix G164
- Monterey Boats Lifetime Limited Warranty164

Related product manuals

Preview: Monterey 295SY

Monterey 208 SI

Monterey 190 LS

Preview: Monterey 305 SS

Monterey 305 SS

Monterey 400 Sport

Monterey 218 LS CUDDY

Monterey 220 Explorer Sport