MQ Power DCA25SSIU4F - MAINTENANCE; Table 14. Inspection;Maintenance

PAGE 34 — DCA25SSIU4F 60 HZ GENERATOR • OPERATION MANUAL — REV. #4 (01/17/18)
Table 14. Inspection/Maintenance
10 Hrs
DAILY
250 Hrs
500 Hrs
or Every
12 Months
3000 Hrs
or Every
36 Months
OTHER
Engine
Check Engine Oil and Coolant Levels X
Check Fuel Filter/Water Separator Bowl X
Check Air Cleaner X
Check Air Cleaner Element X
Check for Leaks/Hoses/Clamps X
Check for Loosening of Parts X
Change Engine Oil and Oil Filter *
1
X
Clean Unit, Inside and Outside X
Replace Fuel Filter Elements X
Check Engine Mounts X
Service Battery X
Check Air Intake Hoses X
Check Fan Belt Condition X
Check Automatic Belt Tensioner X
Check Electrical Ground Connection X
Clean Radiator, Check Cooling System X
Coolant Solution Analysis, Add SCA's As Required X
Pressure Test Cooling System X
Check Engine Speed X
Test Thermostats X
Test Glow Plugs X
Flush and Refill Cooling System 2 yrs. or 2000 hrs.
Clean Inside of Fuel Tank 1000 hrs.
Replace Air Cleaner Elements *
2
As Required
Generator
Measure Insulation Resistance Over 3M ohms X
Check Rotor Rear Support Bearing X
*
1
During initial operation of a new engine, change oil and filter between a minimum of 100 hrs. and a maximum of 250 hrs. Service interval depends
on type of oil.
*
2
Replace primary air filter element when restriction indicator shows a vacuum of 625 mm (25 in. H
2
0).
MAINTENANCE