Napoleon MIRAGE 485 - User Manual

Other manuals for Napoleon MIRAGE 485

Assembly And Operating Instructions60 pages

Manual76 pages

User Guide64 pages

Questions and Answers

A
Austin SimmonsSep 17, 2025
How to fix low heat or low flame on my Napoleon Grill when the valve is on high?
- R
  Ryan FordSep 18, 2025
  If your Napoleon Grill has low heat or a low flame, especially when the valve is turned to high, there are a few potential causes. For propane grills, ensure you are following the correct lighting procedure: all gas grill valves must be in the off position when the tank valve is turned on, and turn the tank on slowly to allow pressure to equalize. For natural gas grills, the supply line might be undersized. For both gas types, improper preheating could be the issue. Pre-heat the grill with all main burners on high for 10 to 15 minutes.
S
sarahritterAug 25, 2025
What to do if my Napoleon MIRAGE 485 has low heat or low flame?
- W
  Walter GibbsAug 25, 2025
  If your Napoleon Grill has low heat or a low flame when the valve is turned to high, it could be due to several reasons. If using propane, ensure you are following the correct lighting procedure, with all gas grill valves in the off position when the tank valve is turned on, and turn the tank on slowly to allow pressure to equalize. If using natural gas, the supply line might be undersized, so the pipe must be sized according to installation code. For both propane and natural gas, improper preheating could be the cause. Pre-heat the grill with both main burners on high for 10 to 15 minutes.
N
Nicholas GreenAug 26, 2025
Why does the 'paint' appear to be peeling inside my Napoleon MIRAGE 485 lid?
- C
  Christina LewisAug 26, 2025
  The 'paint' appearing to peel inside your Napoleon Grill lid is not actually paint. The finish on the lid and hood is stainless steel and will not peel. The peeling is caused by hardened grease, which dries into paint-like shards that flake off. Regular cleaning will prevent this.
W
William MercerAug 27, 2025
Why do the burners on my Napoleon Grill burn with a yellow flame and smell of gas?
- K
  Kelly RodriguezAug 27, 2025
  If the burners on your Napoleon Grill burn with a yellow flame and are accompanied by the smell of gas, it may be due to a possible spider web or other debris, or improper air shutter adjustment. Thoroughly clean the burner by removing it, and open the air shutter slightly according to combustion air adjustment instructions.
C
Cassandra EvansSep 18, 2025
What to do if the 'paint' is peeling inside the lid of my Napoleon Grill?
- D
  David BrennanSep 18, 2025
  If you notice what appears to be paint peeling inside the lid or hood of your Napoleon Grill, don't worry, this isn't a defect. The peeling is actually caused by hardened grease that has dried into paint-like shards and is flaking off. Regular cleaning will prevent this build-up.
L
Lisa FrancoSep 23, 2025
Why does the regulator on my Napoleon MIRAGE 485 Grill hum when it's operating?
- M
  Mrs. Samantha CervantesSep 23, 2025
  The regulator on your Napoleon Grill might hum when the unit is operating, especially on hot days. This is a normal occurrence and not a defect. It's caused by internal vibrations in the regulator and does not affect the performance or safety of the grill.
T
Thomas MartinezSep 9, 2025
Why is “paint” peeling inside the lid of my Napoleon MIRAGE 485 Grill?
- M
  Mary YuSep 9, 2025
  If it appears that "paint" is peeling inside the lid or hood of your Napoleon Grill, don't worry, it's not a defect. The finish on the lid and hood is porcelain, which doesn't peel. What you're seeing is hardened grease that has dried into paint-like shards and is flaking off. Regular cleaning will prevent this.
S
Stephanie BassSep 10, 2025
What to do if Napoleon MIRAGE 485 burners burn with yellow flame and smell of gas?
- J
  Janice SimonSep 10, 2025
  A yellow flame accompanied by the smell of gas in your Napoleon Grill burners could be caused by a spider web or other debris, or an improperly adjusted air shutter. Thoroughly clean the burner by removing it. A qualified gas installer should slightly open the air shutter according to the combustion air adjustment instructions.
M
mturnerSep 3, 2025
Why does the 'paint' appear to be peeling inside the lid of my Napoleon MIRAGE 485?
- S
  slaneSep 3, 2025
  If you see what appears to be peeling 'paint' inside the lid or hood of your Napoleon Grill, this is not a defect. The finish on the lid and hood is porcelain, and it will not peel. The peeling is caused by hardened grease, which dries into paint-like shards that flake off. Regular cleaning will prevent this.
L
Lauren Morales MDSep 1, 2025
What to do if the infrared burner on my Napoleon Grill flashes back?
- J
  Jeremy EverettSep 1, 2025
  If the infrared burner on your Napoleon Grill flashes back, making a loud 'whoosh' sound and growing dim, it could be due to ceramic tiles overloaded with grease, clogged ports, overheating from inadequate ventilation, cracked ceramic tiles, or a leaking gasket. Turn the burner off and let it cool for at least two minutes. Relight the burner and let it burn on high for at least five minutes, or until the ceramic tiles are evenly glowing red. Make sure no more than 75% of the grill surface is covered. If cracks are found, contact your authorized Napoleon dealer to order a replacement burner assembly.

Summary

Napoleon Gas Grill Presidents Limited Warranty

Warranty Conditions and Limitations

Specifies the terms and restrictions of the manufacturer's warranty for the gas grill.

Safe Operating Practices

Cylinder Specification and Gas Hook Up

Propane Cylinder Specifications

Details the requirements and standards for propane cylinders used with the grill.

Propane Cylinder Installation

Provides step-by-step instructions for safely connecting a propane cylinder to the grill.

Natural Gas Hook-Up

Leak Testing Instructions

Outlines the procedure for checking gas connections for leaks using soap and water solution.

Lighting Instructions

Main Tube Burner Lighting

Step-by-step guide for safely igniting the primary burners of the gas grill.

Rear Burner Lighting

Instructions for lighting the rear burner, often used with a rotisserie.

Side Burner Lighting

Guide on how to light the side burner, if the unit is equipped with one.

Operating The Grill

Main Burner Use

Guidance on preheating and using the main burners for various cooking methods.

Direct Cooking Method

Explanation of direct grilling technique for searing and quick-cooking foods.

Indirect Cooking Method

Explanation of indirect grilling technique for slower cooking of larger cuts of meat.

Rear Burner and Rotisserie Use

Instructions for using the rear burner, especially with the rotisserie kit.

Infrared Side Burner Operation

How to operate the infrared side burner, including positioning and cooking tips.

Infrared Burner Protection

Infrared Grilling Chart

Maintenance and Cleaning Instructions

Combustion Air Adjustment

Guidance for adjusting the air shutter for optimal burner flame quality.

Grids and Warming Rack Cleaning

Control Panel Cleaning

Instructions for cleaning the control panel without damaging the printed text.

Cleaning Inside the Gas Grill

Procedures for cleaning internal components like sear plates and burners.

Drip Pan Maintenance

How to clean and maintain the drip pan to prevent grease fires.

Exterior Surface Cleaning

Guidelines for cleaning the grill's painted, porcelain, or stainless steel exterior surfaces.

Burner Reinstallation

Important steps for correctly reinstalling burners after cleaning or maintenance.

Troubleshooting Guide

Ordering Replacement Parts

Warranty Information Requirements

Information needed for warranty claims, including model and serial numbers.

Grill Assembly Instructions

Magnet Installation

Attaching the magnetic catch to the front of the bottom shelf.

Caster and Bracket Installation

Attaching casters and support brackets to the grill cart base.

Propane Tank Ring Installation

Securing the ring for the propane tank.

Left and Right Cart Panel Installation

Installing the side panels of the grill cart.

Rear Cart Panel Installation

Fitting and fastening the rear panel of the grill cart.

Condiment Basket and Propane Tank Mount Installation

Installing the condiment basket and propane tank mount.

Front Cabinet Support Installation

Attaching the front cabinet's top rail and magnet bracket.

Propane Tank Heat Shield Installation

Mounting the heat shield for the propane tank.

Grill Head Installation

Lifting and securing the main grill head onto the assembled cart.

Battery Pack and Rotisserie Mount Installation

Installing the battery pack for LED lights and the rotisserie mount.

Assembling End Caps to Side Shelf

Attaching the end caps to the side shelf components.

Side Shelf Installation

Mounting the side shelves onto the grill base.

Side Burner Installation

Installing the side burner assembly, including the orifice and clip.

Cabinet Door Installation

Hanging and securing the cabinet doors using pivot rods and bushings.

Sear Plate Installation

Placing the sear plates over the tube burners with slots directed downwards.

Grids and Warming Rack Installation

Positioning the cooking grids and warming rack within the grill body.

Grease Tray and Holder Installation

Attaching the grease tray holder and placing the disposable grease tray.

Drip Pan Installation

Sliding the drip pan into its designated position at the rear of the grill base.

Rotisserie Kit Assembly Instructions

Propane Hose Connection Safety

Proper Propane Hose Connection

Demonstrates the correct way to connect the propane gas hose.

Improper Propane Hose Connection Warning

Highlights fire hazards from incorrect propane hose routing or attachment.

Natural Gas Hose Connection Safety

Proper Natural Gas Hose Connection

Shows the correct method for connecting the natural gas hose.

Improper Natural Gas Hose Connection Warning

Warns about fire hazards from incorrect natural gas hose routing.

Leak Testing Procedures

Napoleon MIRAGE 485 Specifications

General

Cooking Area	485 sq. in.
Burners	4
Material	Stainless Steel
Fuel Type	Propane or Natural Gas
Total BTU	48, 000 BTU
Side Burner	12, 000 BTU
Warranty	Limited Lifetime