Home
Napoleon
Pellet stove
NPS45
Napoleon NPS45 User Manual
4
of 1
of 1 rating
56 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
W415-0702 / B / 04.04.12
20
4.5.1 HORIZONT
AL EXHA
UST THROUGH WALL INST
ALLA
TION
4.5.2 THROUGH THE WALL WITH VER
TICAL RISE / HORIZONT
AL TERMINA
TION
Floor
Protection
12” Minimum
Outside Air
(Recommended)
6”
Minimum
3” Minimum
W
all
Thimble
1
1 5/8”
5’
Maximum
17”
W
all Thimble
Outside Air
(Recommended)
3”
2”
Floor
Protection
6”
Minimum
1
1 5/8”
17”
19
21
Table of Contents
Default Chapter
1
Safety Information
1
Table of Contents
2
1 Installation Overview
3
Stove
3
Insert
4
2 Introduction
5
Dimensions
6
Stove
6
Npi45 Complete with Ni800 Flashing
6
Npi45 Complete with Ak8 Adapter and Gicsk Flashing
7
Npi45 Complete with Ak9 Adapter and Cisk Flashing
8
Specifications
9
Heating Specifications
9
General Instructions
9
General Information
10
Pellet Specifications
10
Safety Features
11
Epa Compliance
11
Rating Plate Information
12
3 Installation Planning
13
Appliance Placement
13
Installation Options
13
Stove Minimum Clearance to Combustibles
14
Straight Installation
14
Corner Installation
14
Alcove Installation Requirements (Minimum)
15
Floor Protection Requirements Installation
16
Outside Air
17
Mobile Home
17
4 Venting
18
Type of Vent
18
Installing the Pellet Vent
18
Venting the Pellet Appliance
18
Pellet Vent Termination
19
Vent Terminal Clearances
19
Horizontal Exhaust through Wall Installation
20
Through the Wall with Vertical Rise / Horizontal Termination
20
Minimum Inside Vertical Clearances
21
Class a Chimney Retrofit
21
Hearth Mount Installation
22
Insert Venting Installation Examples
23
Typical Existing Masonry Installation
23
Factory Built Fireplace
24
5 Framing (Insert Only)
25
Installation into a Combustible Enclosure
26
Minimum Enclosure Clearances
27
Minimum Clearance to Combustibles
27
Minimum Mantel Clearances
28
Rear to Top Vent Conversion Instructions
29
6 Finishing
29
Installing Viewing Door
29
Flashing Installation
30
Trivet Installation
30
7 Wiring Diagram
31
8 Operating Instructions
32
Proper Pellet Loading
32
Start up Cycle
32
Lighting Appliance Manually
32
Lighting Instructions
33
Controls
33
Control Adjustment
34
Installing a Thermostat or Remote Control
35
Shutdown Instructions
35
9 Normal Operating Sounds
36
10 Maintenance
37
Daily (Whenever Using the Appliance)
37
Opening Main Door
37
Disposal of Ashes
37
Inspect the Burn Pot
37
Care of Plated Parts
37
Care of Glass
38
Cleaning the Heat Exchanger Tubes
38
Make Sure Pellets Are Not Piling up
38
Cleaning the Burn Pot
39
Bi-Weekly (or Every 10 Bags of Pellets)
39
Vacuum Firebox
39
Semi-Annually (or Every Two Tons of Pellet)
40
Vacuum Hopper
40
Soot and Fly Ash Formation
40
Clean the Vertical Exhaust Duct
40
Clean Exhaust Housing (Insert Only)
41
Clean the Exhaust Blower
41
Check All Seals
41
Clean the Vent
42
In the Event of a Jammed Auger
42
11 Replacements
43
Common Replacement Parts
46
Nps45 Replacement Parts
47
Npi45 Replacement Parts
48
Common Accessory Parts
49
Npi45 Accessory Parts
49
12 Troubleshooting
50
13 Warranty
53
14 Service History
54
Other manuals for Napoleon NPS45
Maintenance & Cleaning
6 pages
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Napoleon NPS45 and is the answer not in the manual?
Ask a question
Napoleon NPS45 Specifications
General
Brand
Napoleon
Model
NPS45
Category
Pellet stove
Language
English
Related product manuals
Napoleon NPS40
48 pages
Napoleon NPI45
56 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
