FORM NO. 56043094 / Captor
™
4300, 4800, 5400 / CR 1100, 1200, 1400 - 1
TABLE OF CONTENTS
SOLUTION SYSTEM ................................................................................................................................38-39
SOLUTION TANK REMOVAL ...................................................................................................................... 38
SOLUTION VALVE CONTROL CABLE REPLACEMENT ............................................................................ 38
TROUBLESHOOTING GUIDE ..................................................................................................................... 38
SOLUTION SYSTEM MAINTENANCE ........................................................................................................ 38
SCRUBBING SYSTEM .............................................................................................................................40-41
SCRUB DECK ASSEMBLY REMOVAL ........................................................................................................ 40
SCRUB DECK ASSEMBLY INSTALLATION................................................................................................ 40
SCRUB DECK CYLINDER REMOVAL ........................................................................................................ 40
SCRUB BRUSH MOTOR REMOVAL........................................................................................................... 40
RECOVERY SYSTEM ...............................................................................................................................42-43
TROUBLESHOOTING GUIDE ..................................................................................................................... 42
VACUUM/RECOVERY SYSTEM SERVICE MAINTENANCE CHECKLIST ................................................. 42
RECOVERY TANK REMOVAL..................................................................................................................... 42
VACUUM FAN MOTOR REPLACEMENT.................................................................................................... 43
SQUEEGEE SYSTEM ............................................................................................................................... 44-47
SQUEEGEE MAINTENANCE ...................................................................................................................... 44
REMOVAL OF SQUEEGEE MOUNT ASSEMBLY ........................................................................................ 46
SQUEEGEE LIFT CYLINDER REMOVAL .................................................................................................... 46
ELECTRICAL SYSTEM ............................................................................................................................48-49
A1 MAIN CONTROL BOARD REMOVAL ..................................................................................................... 48
ENGINE DISABLED ECM REMOVAL .....................................................................................................48-49
ENGINE SYSTEM.............................................................................................................................................*
Note: All references to right, left, front, or rear in this manual are as seen from the operator’s stand-point.
*See OTHER MANUALS AVAILABLE for list of available engine information.
revised 1/06
To Next Page
Loading...
Need help?
General
