Norcold DE0041 - Contents General Information; Table of Contents; General Information; Safety

2 DE/EV0041, DE/EV0061 Models
General Information
Safety
Read this manual carefully and understand the contents
before working on the refrigerator.
Be aware of possible safety hazards when you see the safety
alert symbol on the refrigerator and in this manual. A signal
word follows the safety alert symbol and identifi es the danger
of the hazard. Carefully read the descriptions of these signal
words to fully know their meanings. They are for your safety.
WARNING! This signal word means a hazard, which if
ignored, can cause dangerous personal injury, death.
!
CAUTION! This signal word means a hazard, which
if ignored, can cause small personal injury or much property
damage.
!
Contents
General Information .............................................................................. 2
Safety ........................................................................................... 2
WARNINGS! ................................................................................ 5
Specifi cations ........................................................................................ 6
Cabinet Assembly / .............................................................................. 9
Remove Refrigerator ..........................................................................11
Thermostat ..........................................................................................11
Remove - Thermostat ................................................................11
Enlèvement du réfrigérateur ................................................................11
Enlèvement du réfrigérateur ................................................................11
Desmontar el refrigerador ....................................................................11
Install - Thermostat ................................................................... 12
Control Module ................................................................................... 12
Remove - Control Module ......................................................... 12
Install - Control Module ............................................................. 12
Instalar el termostato ................................................................. 12
Resistor ............................................................................................... 13
Remove - Resistor .................................................................... 13
Reconnect Wiring ....................................................................... 13
Cooling Unit ...................................................................................... 14
Remove - Cooling Unit ............................................................... 14
Install - Cooling Unit .................................................................. 14
Relay ................................................................................................... 14
Remove - Relay ......................................................................... 14
Install - Relay ............................................................................ 14
Installation de l'unité de refroidissement .................................... 14
Troubleshooting .................................................................................. 15
Diagnostic Pre-checks ............................................................... 15
Self-Test Diagnostics .................................................................16
Self-Test Diagnostic Chart .........................................................18
Diagnostic Symptom Chart ........................................................ 18
Troubleshooting - Test A, Battery Protection Cut-Out ............... 21
Troubleshooting - Test B,
Fan- Over Current Cut-Out ....................................................... 22
Troubleshooting - Test C, Motor Start Error ............................... 22
Troubleshooting - Test D, Minimum Motor Speed Error ............ 23
Troubleshooting - Test E, Thermal Cut-Out of Electronic Unit .. 23
Troubleshooting - Test F, Not Cooling, Not Turning On .............. 24
Troubleshooting - Test G, Refrigerator Gets Too Cold .............. 25
Troubleshooting - Test H, Refrigerator Builds Frost Inside ....... 25
Troubleshooting - Test I, Runs But Does Not Cool Properly ...... 26
Troubleshooting - Test J, Will Not Run On DC Power ................ 26
Wiring Diagram ................................................................................... 27