6
• • • User Manual ref1109
1.5 Points of Attention
• The OT200 is designed to lift and transfer caretakers in combination with an appropriate sling, the
OT200 can only be used for this purpose. Any other form of use is not allowed.
• It is not allowed to lift more than 200kg (440lbs) with the OT200, unless otherwise stated on the lift.
The OT400 can lift 400kg.
• It is not allowed to lift any object (e.g. a chair or wheelchair) together with the caretaker.
• Special caution needs to be taken when the clips of a sling are attached to the hanger bar, incorrectly
attaching these clips can cause a fall of the caretaker and lead to severe injuries.
• Always make sure sufficient space is available above the caretaker before lifting.
• Only use the OT200/OT400 in combination with a sling that is delivered by OpeMed. Always contact
OpeMed before using alternative slings.
• Treat the lift with care and always make sure the working environment is neat and clean.
• Working with the hoist is only allowed to authorized personnel.
• The OT200/OT400 needs at least once a year a periodical inspection.
• Service and maintenance of the hoist is only allowed to be carried out by authorized personnel.
• Only use original parts (supplied by OpeMed) for repairs or replacements.
• Replacing hanger bars or other constructive parts of the hoist is only allowed to authorized personnel.
• Charging the battery always needs to be done in well ventilated, dry rooms. Battery chargers need to
be connected according to the installation demands.
• Battery chargers need a periodical inspection at least once a year.
• Never lift the caretaker higher than necessary.
• When deformations occur to the hoist due to incorrect usage or transport, the hoist should not be used
anymore, and will have to be sent back to the supplier.
• Avoid collision into end stops at full speed.
• Move the hoist carefully in order to prevent excessive movements of the caretaker.
• Never leave the hoist unattended while loaded. In energy saving mode (after 10 minutes) the load will
be lowered slowly.
• Do not use the hand-held control or the hanger bar wires as towing-lines to move the caretaker as this
will damage the wiring.
To Next Page
Loading...
