Perkins 404C-22T Service Manual

i07792922
Maintenance Interval Schedule
Ensure that the Safety Information, Warnings,
and Instructions are read and understood before
operation or maintenance procedures are
performed.
Note: The frequency that the engine oil is changed
will be affected if the load factor for the engine is
greater than 40 percent. Consult your Perkins
distributor if assistance is required to calculate the
load factor for your engine.
Before each consecutive interval is performed, all of
the maintenance requirements from the previous
interval must also be performed.
When Required
“ Battery - Replace” . . . . . . . . . . . . . . . . . . . . . . . . . 57
“ Battery or Battery Cable - Disconnect”. . . . . . . . . 58
“ Engine - Clean” . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
“ Engine Air Cleaner Element - Replace” . . . . . . . . 65
“ Fuel System - Prime”. . . . . . . . . . . . . . . . . . . . . . . 72
“ Severe Service Application - Check” . . . . . . . . . . 79
Daily
“ Cooling System Coolant Level - Check”. . . . . . . . 62
“ Driven Equipment - Check” . . . . . . . . . . . . . . . . . . 64
“ Engine Air Cleaner Service Indicator - Inspect” . . 66
“ Engine Oil Level - Check” . . . . . . . . . . . . . . . . . . . 68
“ Fuel System Primary Filter/Water Separator -
Drain” . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
“Walk-Around Inspection” . . . . . . . . . . . . . . . . . . . . 80
Every 50 Service Hours or Weekly
“ Fuel Tank Water and Sediment - Drain” . . . . . . . . 77
Every 250 Service Hours or 6
Months
“ Alternator and Fan Belts - Inspect/Adjust” . . . . . . 56
Every 500 Service Hours
“ Fuel System Filter - Replace” . . . . . . . . . . . . . . . . 74
Every 500 Service Hours or 1 Year
“ Battery Electrolyte Level - Check” . . . . . . . . . . . . 58
“ Cooling System Supplemental Coolant Additive
(SCA) - Test/Add” . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
“ Engine Air Cleaner Element - Replace” . . . . . . . . 65
“ Engine Oil and Filter - Change”. . . . . . . . . . . . . . . 68
“ Hoses and Clamps - Inspect/Replace”. . . . . . . . . 77
“ Radiator - Clean” . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Every 1000 Service Hours
“ Alternator and Fan Belts - Replace” . . . . . . . . . . . 57
“ Engine Valve Lash - Inspect/Adjust”. . . . . . . . . . . 71
“ Turbocharger - Inspect” . . . . . . . . . . . . . . . . . . . . . 80
Every 2000 Service Hours
“ Alternator - Inspect” . . . . . . . . . . . . . . . . . . . . . . . . 56
“ Engine Crankcase Breather - Replace” . . . . . . . . 67
“ Engine Mounts - Inspect” . . . . . . . . . . . . . . . . . . . 68
“ Starting Motor - Inspect” . . . . . . . . . . . . . . . . . . . . 79
Every 3000 Service Hours
“ Fuel Injector - Test/Change” . . . . . . . . . . . . . . . . . 71
54
SEBU7992-05
Maintenance Section
Maintenance Interval Schedule

Perkins 404C-22T Specifications

General

Brand	Perkins
Model	404C-22T
Category	Engine
Language	English