15January 8, 2019 7082-154E
TREKKER INSERT
Figure 15.2
Figure 15.1 - Fire pot with large clinker
C. General Maintenance and Cleaning
1. Cleaning Fire pot using Lever
• Frequency: Daily or as needed*
• By: Homeowner
a. Be sure the appliance is allowed to cool.
b. Open cast face of appliance
c. Pull re pot oor cleaning lever two times until the
ash falls into the ash pan below (Figure 15.2).
d. It may be necessary to use your re pot clean-out
tool to chip away material that has built up on the
sides of the re pot and to push out any clinkers
(Figure 15.1).
e. Larger clinkers may have to be removed from the
top of the re pot.
f. If the clinker adheres to the sides of the re pot,
you will need to manually clean the re pot. The re
pot oor plate must be fully closed when nished.
2. Cleaning Ash Pan
• Frequency: Weekly or every 3-5 bags
• By: Homeowner
a. Locate the ash pan underneath the re pot.
b. Slide the ash pan straight out.
c. Empty into a non-combustible container and re-
install ash pan.
d. When replacing ash pan push it back until it
catches on the 2 side latches.
Clinkers lling the ash pan will have to be cleaned out more
often than ash.
Ash Disposal:
Ashes should be placed in a steel container with a tight-
tting lid. The container of ashes should be moved outdoors
immediately and placed on a non-combustible oor or on
the ground, well away from combustible materials, pending
nal disposal.
If the ashes are disposed of by burial in soil or otherwise
locally dispersed, they should be retained in the closed
container until all cinders have thoroughly cooled. Other
waste shall not be placed in this container.
3. Ash Removal from Firebox
• Frequency: Weekly or more frequently depending on
ash build-up
• By: Homeowner
a. Be sure the appliance is allowed to cool.
b. There must not be any hot ashes in the rebox
during cleaning.
c. Frequent cleaning of the ash in the rebox with a
vacuum cleaner will help slow down the build-up of
ash in the exhaust blower and vent system.
RISK OF FIRE
Keep combustible materials, gasoline and other
ammable vapors and liquids clear of appliance.
• Do NOT store ammable materials in the
appliance’s vicinity.
• Do NOT use gasoline, lantern fuel, kerosene,
charcoal lighter uid or similar liquids to start
or “freshen up” a re in this heater.
Keep all such liquids well away from the heater
while it is in use as combustible materials may
ignite.
WARNING
To Next Page
Loading...
Need help?
General
