Ransomes 61 Super Certes - Maintenance; Maintenance and Lubrication Chart

en-52
10 MAINTENANCE
MAINTENANCE AND LUBRICATION CHART
Interval Item Section
First Month or 20 hours Change Engine Oil 11.3
Each day 10 hours
Check Engine Oil Level 11.1
Check Air Filter Element 10.2
Check Engine for Dirt 11.1
First 50 hours
Clean or Replace Air Filter Element * 11.2
Check and Adjustment of Landroll Clutch
Every 50 hours
Each week
Check for Loose Components
Clean or Replace Air Filter Element * 11.2
Check the Inside Clutch Cover for Dirt
Check Chain Tension
Check Tyre Pressure (Super Certes Only)
Every 100 hours
Change Engine Oil 11.3
Clean and Check the Spark Plug
Every 200 hours
Each month
Check and Adjust Primary Drive Clutch
Check and Adjust the Cylinder Clutch
Check Parking Brake Adjustment
End of Season
Change Engine Oil 11.3
Change Air Filter Element 10.2
Replace Fuel Filter
Drain and Clean Fuel Tank
Check all Chains for Indications of Wear or Damage
Lubricate all Grease Fittings Each week (see chart)
* Service Frequently in Dirty Conditions
Refer to Engine Manufactures Manual for Additional Engine Maintenance Procedures
11.1
11.3