EasyManua.ls Logo

Raypak CROSSWIND-30-I - User Manual

Raypak CROSSWIND-30-I
28 pages
Save Page as PDF
Print Icon
To Next Page IconTo Next Page
To Next Page IconTo Next Page
Loading...
Catalog No. 6100.64
E󰀨ective: 11-15-19
Replaces: New
P/N 241827 Rev.1
INSTALLATION
AND OPERATION
MANUAL
FOR YOUR SAFETY: Do not store or use gasoline or other ammable vapors and
liquids or other combustible materials in the vicinity of this or any other appliance. To
do so may result in an explosion or re.
Crosswind
Side Discharge
Heat Pump Pool Heater
NOTE: The instructions in this manual are for the use of qualied individuals specially trained and experienced
in the installation and maintenance of this type of equipment and related system components. Installation and
service personnel are required by some states to be licensed. Persons not qualied shall not attempt to install,
service, or maintain this equipment.
This manual should be maintained in legible condition and kept adjacent to the heat pump pool heater or in a
safe place for future use.
Inverter Models
CROSSWIND-30-I through -65-I
On/O󰀨 Models
CROSSWIND-40-O through -65-O
(Canada Only)
6100.64_Crosswind.indd 1 11/26/2019 4:16:40 PM

Table of Contents

Questions and Answers

  • P
    Paige FuentesAug 7, 2025
    What to do if Raypak Swimming Pool Heater runs but does not heat?
    • W
      Wendy ThomasAug 7, 2025
      If your Raypak Swimming Pool Heater's heat pump runs but doesn't heat, ensure that neither the air inlet nor the air outlet are blocked by any obstructions. Also, check that the temperature isn't set too low and adjust the temperature setting if needed. If the unit has just been started, wait at least three minutes for the warming process to begin, as it may be in a protection mode.
  • S
    Stephanie WilkersonAug 23, 2025
    How to fix Raypak Swimming Pool Heater if it does not run?
    • J
      Jessica OlsenAug 23, 2025
      If your Raypak Swimming Pool Heater's heat pump does not run, first, ensure that the main power is on. If it is, check whether the power switch is turned on. Also, inspect the fuse and replace it if it's burnt. Finally, verify that the circuit breaker hasn't tripped, and if it has, turn it back on. Wait for the power to be restored if it's off.

Summary

Register Your Unit

Warnings and Safety Terms

Pay Attention to These Terms

Defines DANGER, WARNING, CAUTION, and NOTE symbols for hazard communication.

General Precautions

Water Chemistry Management

Corrosive Water Damage Warning

Before Installation and Considerations

Installation Requirements

Specifies mandatory requirements for heater installation, including professional installation.

Electrical Wiring and Connections

Automation Control Wiring

Water Connections and Piping

Wiring Diagrams

Inverter Models Wiring Diagrams

Contains schematics for Crosswind 30-I, 40-I, 50-I, and 65-I models.

On;Off Models Wiring Diagrams

Includes schematics for Crosswind 30-O, 40-O, and 50-O models.

Inverter Model Controls and Display

On;Off Model Controls and Display

Operating Instructions and Start-Up

Model Identification and Water Flow

Maintenance and Cold Weather Operation

Troubleshooting Common Faults

Fault Codes for Inverter Models

Limited Warranty Information

Warranty Periods and Costs

Warranty Exclusions

Making a Warranty Claim and Liability

How to Make a Warranty Claim

Step-by-step guide on how to initiate a warranty claim.

Exclusive Warranty and Limitation of Liability

Raypak CROSSWIND-30-I Specifications

General IconGeneral
BrandRaypak
ModelCROSSWIND-30-I
CategorySwimming Pool Heater
LanguageEnglish

Related product manuals