Raypak 106 - User Manual

INSTALLATION & OPERATING
INSTRUCTIONS
CATALOG NO. 6100.62B Effective: 12-18-13 Replaces: 06-21-13 P/N 241519 Rev. 3
WARNING: If the information in these
instructions are not followed exactly, a fire or
explosion may result causing property
damage, personal injury or death.
FOR YOUR SAFETY: Do not store or use
gasoline or other flammable vapors and
liquids or other combustible materials in the
vicinity of this or any other appliance. To do
so may result in an explosion or fire.
WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas suppli-
er's instructions.
• If you cannot reach your gas supplier, call
the fire department.
Installation and service must be performed by
a qualified installer, service agency or the gas
supplier
.
This manual should be maintained in legible condition and kept adjacent to the heater or in another safe place for
future reference.
Models 106 & 156
Atmospheric
Above-Ground
Pool & Spa
Heater
(Chauffe-Piscine)
English/French
AVERTISSEMENT: Assurez-vous de bien suivre
les instructions données dans cette notice pour
réduire au minimum le risque d’incendie ou
d’explosion ou pour éviter tout dommage matériel,
toute blessure ou la mort.
Ne pas entreposer ni utiliser d’essence ou ni
d’autres vapeurs ou liquides inflammables à
proximité de cet appareil ou de tout autre appareil.
CE FAIRE SI VOUS SENTEZ UNE ODEUR
DE GAZ:
• Ne pas tenter d’allumer d’appareil.
• Ne touchez á aucun interrupteur; ne pas
vous servir des téléphones se trouvant dans
la bâtiment.
• Appelez immédiatement votre fournisseur
de gaz depuis un voisin. Suivre les instruc-
tions du fournisseur.
• Si vous ne pouvez rejoindere le fournisseur,
appelez le service es incendies.
L’installation et l’entretien doivent être assurés
par un installeur qualifié ou par le fournisseur de
gaz.

Summary

Safety Information

Warning Terms and Definitions

Explains DANGER, WARNING, CAUTION, and NOTE terms used in the manual.

Gas Leak Procedures

Steps to follow if a gas smell is detected, including safety warnings.

Water Chemistry Management

Water Chemistry Guidelines

Recommended levels for pool and spa water balance, including chemical parameters.

Heater Installation

Installation Codes and Clearances

Compliance with national codes and required spacing from combustible surfaces.

Location and Mounting Requirements

Guidance on base installation, indoor/outdoor placement, and proximity rules.

Gas, Water, and Vent Piping

Electrical Connections

Troubleshooting and Diagnostics

Mechanical Troubleshooting

Guide to diagnosing and resolving common mechanical issues.

Electronic Control Logic

Analog Control Logic

Raypak 106 Specifications

General

Type	Swimming Pool Heater
Fuel Type	Natural Gas or Propane
Efficiency	82%
Heat Exchanger	Cupro-Nickel
Warranty	1 Year Limited